《4000吨每天水泥回转窑烟气除尘工程设计1.doc》由会员分享，可在线阅读，更多相关《4000吨每天水泥回转窑烟气除尘工程设计1.doc（6页珍藏版）》请在三一办公上搜索。
1、4000吨每天水泥回转窑烟气除尘工程设计本科毕业设计（论文）4000t/d水泥回转窑烟气除尘工程设计学 院 环境科学与工程学院 专 业 环 境 工 程 年级班别 20XX级（X）班 学 号 310X008XXX 学生姓名 XXX 指导教师 XX 20XX年 X 月设计总说明设计任务由来：为了控制水泥工业的大气污染物排放，促进水泥工业产业结构调整，国家环境保护总局组织中国环境科学研究院、合肥水泥研究设计院、中国材料工业科工集团公司起草了新的水泥工业大气污染物排放标准（GB4915-2004）。水泥回转窑窑尾是水泥生产环节中粉尘排放量最大的排放点，窑外分解窑尾烟尘浓度为60g/m380g/m3，这
2、一环节的污染物成分复杂，除粉尘、烟尘外，还有二氧化硫、氮氧化物、氟化物等有害气体水泥产量：4000吨/天；烟气温度：45200；烟气含尘浓度：500030000mg/Nm3；烟气湿度：515。设计原则：设计中要认真贯彻国家的经济建设方针、政策。应充分考虑资源的充分利用。选用的技术要先进适用。工程设计要坚持安全可靠、质量第一的原则。坚持经济合理原则必须遵循国家有关环境保护法律、法规，合理开发和充分利用各种自然 资源，严格控制环境污染，保护和改善生态环境建设项目需要配套建设的环境保护设施，必须与主体工程同时设计、同时施工、同时投产使用。 必须遵守污染物排放的国家标准和地方标准。应当在建设项目中采用
3、能耗物耗小、污染物产生量少的清洁生产工艺。关键词：水泥回转窑，烟气，除尘specificationIn order to control the cement industry the air pollutant emissions, the promotion cement industry industrial structure adjustment, Country Environmental protection Bureau organized China Environmental science Research institute, Hefei Cement Research
4、 Design institute, Chinese Material Industry Science and industry Group Company to draft newly Cement industry Air pollutant Emissions Standard GB4915-2004 .The cement rotary kiln kiln tail is in the cement production link the dust withdrawal biggest emission point, outside the kiln decomposes the k
5、iln tail mist and dust density is 60g/m380g/m3, this link pollutant ingredient is complex, except outside dust, mist and dust, but also has the sulphur dioxide, the nitrogen oxide compound, the fluoride and so on the noxious gas, but the dust is most serious to the air pollution.design standardExist
6、ing production line craft, operating mode and related technical data, document materialGuangdong Province Air pollutant Emissions Limiting value DB44/27-2001 Industrial enterprise Designs Hygienic Standard TJ36-79 Cement industry Pollutant Emissions Standard GB4915-85 The rotary kiln related technic
7、al parameter is as follows:Cement output: 4000 tons/days;Haze temperature: 45400;The haze contains the dust density: 500030000mg/Nm3; Haze humidity: 10%20%design philosophy1 In the design must implement national earnestly the principles of national economy, the policy.2 Should consider the resources
8、 fully the full use.3 Selects the technology must be suitable advanced.4 The engineering design needs to persist safely reliable, the quality first principle.5 Persists the economical reasonable principle6 Must follow the country related environmental protection law, the laws and regulations, the re
9、asonable development and uses each natural resource fully,Strict control environmental pollution, protection and improvement ecological environment7 The items of basic construction need to form a complete set the construction environmental protection facility, must simultaneously design with the pri
10、ncipal part of a project, simultaneously construct, simultaneously goes into production the use.8 Must observe the pollutant emissions the national standards and the place standard.9 Must use the energy consumption material and energy consumption slightly in the items of basic construction, the poll
11、utant has the quantity few clean production craft.Key word: Cement rotary kiln, haze, dust removal目录1 概述11.1 水泥工业污染及特征11.2 水泥厂回转窑粉尘污染治理11.3 水泥厂基本情况52 水泥厂回转窑除尘设备的选择62.1 水泥厂回转窑粉尘特点及烟气条件62.2 除尘器选用60. 除尘器的选择要点6. 除尘器的选用原则7. 除尘器的选择83 脉冲布袋除尘器的选型计算和设计113.1设计依据11.据标准11.容113.2 脉冲布袋除尘器的选型计算12. 除尘系统初步设计方案12. 脉冲布袋除尘器相关技术及参数选择13.艺流程设计14.备能力计算154 脉冲布袋除尘器的保温与防腐195 脉冲布袋除尘器的安装、调试、维护和检修205.1安装、调试20.修216 土建设计226.1 土建设计依据及原则226.2 土建工程结构类型设计226.3 建构筑物设计要点226.4 总平面布置227 电气、仪器仪表237.1 供、配电系统237.2 主要电气设备选型237.3 自控、仪器、仪表238 工程投资概算248.1主要设备248.2 总投资概算24.资结算表24.行能耗表24.co
