《外墙涂料施工方案和报价.doc》由会员分享，可在线阅读，更多相关《外墙涂料施工方案和报价.doc（7页珍藏版）》请在三一办公上搜索。
1、外墙涂料翻新施工方案外墙涂料旧房翻新工程施工方案一、 工程概括：1、 工程名称：新东明汇东园区1#、2#厂房和办公楼外墙涂料改造工程2、 工程面积:约2500m2二、施工工艺：1、 基层清理和保护：、用铲刀将原墙面上涂料、腻子、和污染物进行彻底的铲除干净；、用扫把将墙面上的浮灰彻底的清扫干净；、将长时间受雨水冲刷遗留的青苔进行打磨处理；、将竖立在外墙上的空调外机、装饰物等部位进行遮盖保护。2、基层处理:、在清理干净后的墙面上用滚筒均匀的涂刷水剂界面处理剂，不得遗漏；、如墙面龟裂较为严重的大面积墙面，建议界面剂涂刷好后，批嵌一层抗裂网格布、界面剂干燥后，进行第一遍批嵌腻子，待第一遍腻子干燥后，再
2、进行批嵌第二遍腻子，毛刷排刷细纹（常温下12h干燥时间），腻子干燥后进行局部打磨处理。批嵌要求：必须批嵌平整光滑，控制在规范范围内。建议; 采用柔性腻子，可以有效的控制墙面的细微裂纹。3、 底漆涂刷：待腻子层干燥打磨好后可涂刷抗碱底漆，底漆颜色调试到与面漆颜色接近，已提高遮盖率，不同颜色的面漆采用不同颜色的底漆。要求：涂刷均匀不得遗漏。建议：必须采用抗碱底漆，防止碱性渗出，造成面漆局部颜色改变，影响整体效果。4、 面漆涂刷：、先将整体墙面的第一遍面涂涂刷完成，要求涂刷要均匀，不得遗漏；、待第一遍面涂干燥后，再涂刷第二遍面涂，涂刷方法与第一遍相同；、待大面积面涂涂刷完成后，再涂刷小面积的其他颜色
3、面涂，同样为两遍；、如需拉毛的墙面，待底漆涂刷完成，即可涂刷拉毛涂料，拉毛要求均匀，大小一致，不得有接头，拉毛涂料干燥后再涂刷面漆。建议：采用弹性涂料，具有覆盖基材伸缩运动产生细部裂纹的功能，柔韧性好，可塑性极强附着力强，擦洗，耐酸碱，不褪色，维修重涂容易等特点。5、 线条图描：先将分隔线和滴水线条内的杂物清理干净后，再采用油画笔将墙面上的分隔线和滴水线条均匀的图描完成。6、 细部处理;、对已施工完成的整体墙面进行逐层进行检查修补，对于颜色交错的部位、门窗边、管道边、空调边等部位仔细检查，如有露底，遗漏等部位进行修补。、对于在施工过程中涂料污染的部位，要进行清理，如管道、门窗等部位。7、 脚手
4、架拆除：在脚手架拆除时，安排专业人员跟随脚手架，对拆除时造成的污染进行处理。三、施工要求和安全措施：、施工所用的脚手架必须符合规范要求，根据本项目的特点采用移动式脚手架；搭设脚手架时，必须要搭设平稳、安全，拉接到位，验收合格后可使用；拆除时，必须封锁拆除区域，且有专人看管，不得非拆除人员进出，同时要注意成品保护和设施的保护工作。、在施工前，各住户家外墙上的装饰物应拆除，如衣架、花盆、卫星天线等；、在施工中，各住户家的门窗应自行关好，不得开启；、在施工中，施工区域内应采用警戒线封闭，非施工人员不得入内，车辆绕行。、在施工中，高危地区要求佩戴安全带等安全措施。、施工人员必须遵守安全生产手册，正确佩
5、戴安全用品，施工现场不得抽烟，酒后不得上岗等。、在施工期间不得扰民。、施工所需的水电应在施工区域50m内。四、施工进度：施工有效工作日20天内完成，如遇下雨、台风或者非施工人员造成的工期延误，将根据实际情况推延。五、 施工人工报价：脚手架搭设和拆除费用：3元/m2基层处理和工具：2元/m2界面剂涂刷：1元/m2腻子批嵌（2遍）：5元/m2底漆涂刷：1元/m2面漆涂刷（2遍平涂）：3元/m2勾线和细部处理：0.5元/m2合计：15.5元/m2备注：本报价不包含材料费、施工的水电费、脚手架租赁费、管理费、工人的住宿费、工人综合保险的费用及税金；施工中基层处理中如需批嵌网格布的部位将按照4元/m2另
6、外计算。 材料报价：一、 一般涂料饰面报价;序号材料名称平方用量单价平方单价备注1水剂界面处理剂0.2kg/m210元/kg2元/m22刚性腻子2kg/m21.8元/kg3.6元/m23封闭底漆0.2kg/m212元/kg2.4元/m24外墙乳胶漆（平涂）0.7kg/m216元/kg11.2元/m25脚手架租赁费4元/m2可由甲方租赁6合计23.2元/m2二、 弹性涂料饰面报价;序号材料名称平方用量单价平方单价备注1水剂界面处理剂0.2kg/m210元/kg2元/m22柔性腻子2kg/m22.3元/kg4.6元/m23抗碱底漆0.2kg/m215元/kg3元/m24弹性涂料（平涂）0.8kg/
7、m222.5元/kg18元/m25脚手架租赁费4元/m2可由甲方租赁6合计31.6元/m2Acknowledgements My deepest gratitude goes first and foremost to Professor aaa , my supervisor, for her constant encouragement and guidance. She has walked me through all the stages of the writing of this thesis. Without her consistent and illuminating in
8、struction, this thesis could not havereached its present form. Second, I would like to express my heartfelt gratitude to Professor aaa, who led me into the world of translation. I am also greatly indebted to the professors and teachers at the Department of English: Professor dddd, Professor ssss, wh
9、o have instructed and helped me a lot in the past two years. Last my thanks would go to my beloved family for their loving considerations and great confidence in me all through these years. I also owe my sincere gratitude to my friends and my fellow classmates who gave me their help and time in list
10、ening to me and helping me work out my problems during the difficult course of the thesis. My deepest gratitude goes first and foremost to Professor aaa , my supervisor, for her constant encouragement and guidance. She has walked me through all the stages of the writing of this thesis. Without her c
11、onsistent and illuminating instruction, this thesis could not havereached its present form. Second, I would like to express my heartfelt gratitude to Professor aaa, who led me into the world of translation. I am also greatly indebted to the professors and teachers at the Department of English: Profe
12、ssor dddd, Professor ssss, who have instructed and helped me a lot in the past two years. Last my thanks would go to my beloved family for their loving considerations and great confidence in me all through these years. I also owe my sincere gratitude to my friends and my fellow classmates who gave me their help and time in listening to me and helping me work out my problems during the difficult course of the thesis.
