《X3车身附件结构图册(new).doc》由会员分享，可在线阅读，更多相关《X3车身附件结构图册(new).doc（67页珍藏版）》请在三一办公上搜索。
1、四、车 身 附 件 组 CAR BODY ACCESSORIES图4-1序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1BYDF3-8402180发动机罩锁紧装置总成Lock assy， hood12Q1860616六角法兰面螺栓Bolt33BYDX3-8402230发动机罩拉索机构总成Wire assy，hood14BYDX3-8402231发动机罩拉索固定卡扣Clip，wire ASSY，hood25BYDX3-8402210发动机罩左安装铰链总成Hinge ASSY,hood, L16BYDX3-8402220发动机
2、罩右安装铰链总成Hinge ASSY,hood, R17Q1860820TF2六角法兰面螺栓Bolt88Q40208大垫圈Big washer89BYDX3-8402170发动机左气撑总成Stay rod comp，hood，l110BYDX3-8402180发动机右气撑总成Stay rod comp，hood，r111Q1860616TF2六角法兰螺栓 Bolt8125302101（福莱尔)堵片D40Seal2136301101（福莱尔)堵片D23Seal214BYDF3-8402211发动机罩缓冲垫Buffer cushion, hood215BYDX3-5101711前地板圆形封盖Plu
3、g3图4-1图4-2序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1BYDX3-6105030左侧门外拉手总成Outside handle assy, door, L12BYDX3-6105040右侧门外拉手总成Outside handle assy, door , R13BYDX3-6105010左侧门锁体总成Lock COMP, door, L14BYDX3-6105020右侧门锁体总成Lock COMP, door, R15BYDX3-6105911侧门锁固定螺栓Bolt, door36BYDX3-6105200侧门
4、锁环Pin assy., door lock27BYDX3-6105912侧门锁环固定螺栓Bolt, pin assy, door lock48BYDX3-6108010左侧门内扣手总成Inside handle assy, door, L19BYDX3-6108020右侧门内扣手总成Inside handle assy, door, R110Q2734216十字槽打扮圆头自攻螺钉Screw211BYDX3-6102902板簧螺母Nut212BYDX3-6106100上铰链总成Hinge assy, door, upper213BYDX3-6106300左侧门下铰链总成Hinge assy,
5、door, lower, L114BYDX3-6106400右侧门下铰链总成Hinge assy, door, lower, R115Q1860825TF2六角头螺栓Bolt8图4-2图4-2图4.2序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English16Q40208大垫圈Big washer817Q32008六角法兰面螺母Nut218Q32008六角法兰螺母Nut819BYDX3-6107111左侧门窗台外密封条Outer seal, door, L120BYDX3-6107112右侧门窗台外密封条Outer seal, do
6、or, R121BYDX3-6107113左侧门窗台内密封条Inside seal, door, L122BYDX3-6107114右侧门窗台内密封条Inside seal, door, R123BYDX3-5402931侧门窗台内密封条固定卡扣Clip, inside seal, door624BYDX3-6107115左侧门角密封条Seal, door corner , L125BYDX3-6107116右侧门角密封条Seal, door corner, R126BYDX3-6105130侧门外拉手手柄组件Outside handle, door227BYDX3-6105035左锁孔盖Co
7、le-plug, cylinder set, door , L128BYDX3-6105036右锁芯Cole-plug, cylinder set, door, R129BYDX3-6105037小垫圈Small washer230BYDX3-6105330左大垫圈组件Big washer assy，L131BYDX3-6105340右大垫圈组件Big washer assy，R132BYDX3-6105530左锁芯组件Cylinder set, door, L1 图4-2图4-2序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文Engli
8、sh33BYDX3-6105230左侧门手柄安装座总成Base comp, outer handle, door, L134BYDX3-6105240右侧门手柄安装座总成Base comp, outer handle , door, R135BYDX3-3642411反光片Glisten236BYDX3-3642611透光罩Light sensor237BYDX3-3642612透光罩衬圈Light sensor pad238BYDX3-3642613透光罩内垫Light sensor pad239BYDX3-3642400左门把手探测器Detector, left handle140BYDX
9、3-3642500右门把手探测器Detector, right handle133BYDX3-6105230左侧门手柄安装座总成Base comp, outer handle, door, L1图4-3图4-3序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1BYDX3-6107117左侧门底部密封条Seal，lower, door, L12BYDX3-6107118右侧门底部密封条Seal，lower, door, R13BYDX3-6102921侧门底部密封条固定卡扣Clip, seal, lower, door204B
10、YDX3-5101751D20堵盖Plug,D2025BYDF3-5107118地板盖板D30Plug D30,floor26BYDX3-6101717侧门定位套Orientation plug，door27BYDX3-6101714侧门外拉手旁堵盖Plug beside handle, door28BYDX3-6101713侧门底部腰形堵盖Plug, lower, door29BYDX3-6101722粘毡双面胶Double-faced seal210BYDX3-6101721粘毡Seal2图4-4图4-4序号No.零件编号Part No.名 称Description数量Qty备注Rem中文
11、Chinese英文English1BYDX3-3746500左门玻璃升降器电机Motor, left door regulator12BYDX3-3746600右门玻璃升降器电机Motor, right door regulator13BYDX3-6104111左侧门玻璃升降器前导轨Front orbit, left door regulator14BYDX3-6104112右侧门玻璃升降器前导轨Front orbit, right door regulator15BYDX3-6104115左侧门玻璃升降器前导轨上支架Upper bracket, front orbit, left door
12、regulator16BYDX3-6104116右侧门玻璃升降器前导轨上支架Upper bracket, front orbit, right door regulator17BYDX3-6104117左侧门玻璃升降器前导轨下支架Nether bracket, front orbit, left door regulator18BYDX3-6104118右侧门玻璃升降器前导轨下支架Nether bracket, front orbit, right door regulator19BYDX3-6104113左侧门玻璃升降器后导轨Rear orbit, left door regulator11
13、0BYDX3-6104114右侧门玻璃升降器后导轨Rear orbit, right door regulator111BYDX3-6104121左侧门玻璃升降器后导轨上支架Upper bracket, rear orbit, left door regulator112BYDX3-6104122右侧门玻璃升降器后导轨上支架Upper bracket, rear orbit, right door regulator1图4-4图4-4序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English13BYDX3-6104123左侧门玻璃升降
14、器后导轨下支架Nether bracket, rear orbit, left door regulator114BYDX3-6104124右侧门玻璃升降器后导轨下支架Nether bracket, rear orbit, right door regulator115BYDX3-6104141侧门玻璃升降器拉丝轮Drawbench wheel, door regulator816BYDX3-5404918升降器拉丝轮铆钉Rivet, drawbench wheel, door regulator817BYDX3-6104110侧门玻璃升降器拉丝总成Drawbench 1, door regu
15、lator218BYDX3-6104120侧门玻璃升降器拉丝总成Drawbench 2, door regulator219BYDX3-6104130侧门玻璃升降器拉丝总成Drawbench 3, door regulator220BYDX3-6104151侧门玻璃升降器拉丝固定扣Fixing clip, Drawbench, door regulator221BYDX3-6104125左侧门玻璃升降器电机安装支架Motor fixing bracket, left door regulator122BYDX3-6104126右侧门玻璃升降器电机安装支架Motor fixing bracket
16、, right door regulator123BYDX3-6104127左侧门玻璃升降器前滑块Front sliding block, left door regulator124BYDX3-6104128右侧门玻璃升降器前滑块Front sliding block, right door regulator1图4-4图4-4序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English25Q2150665内六角花形盘头螺钉Hexagon socket bolt with plate head426BYDX3-6104918升降器滑块
17、塞块连接螺母Nut, T block, sliding block, door regulator427BYDX3-6103115车窗玻璃前螺母板胶条Rubber belt, front nut panel, side window228BYDX3-6103113左车窗玻璃前螺母板Front nut panel, left side window129BYDX3-6103114右车窗玻璃前螺母板Front nut panel, right side window130BYDX3-6104131侧门玻璃升降器前滑块塞块Front T block, sliding block, door regu
18、lator231BYDX3-6104713侧门玻璃升降器前滑块上胶座Plastic cap, front sliding block, door regulator232Q32006六角法兰面螺母Nut 633BYDX3-6104711升降器导轨上支架上缓冲胶套Cushion, Upper bracket,orbit,door regulator434BYDX3-6104914升降器导轨上定位拉钉Nail, orbit,door regulator635Q1860825TF2六角法兰面螺拴Bolt 图4-4图4-4序号No.零件编号Part No.名 称Description数量Qty备注Re
19、m中文Chinese英文English36Q40208大垫圈Big washer237BYDX3-6104132侧门玻璃升降器后滑块塞块Rear T block, sliding block, door regulator238BYDX3-6104133左侧门玻璃升降器后滑块Rear sliding block, left door regulator139BYDX3-6104133左侧门玻璃升降器后滑块Rear sliding block, right door regulator140BYDX3-6103121车窗玻璃后螺母板Rear nut panel, side window241BY
20、DX3-6103117车窗玻璃后托架Rear side-widow-bracket242BYDX3-6101715海绵垫Sponge cushion443BYDX3-6104811粘毡Felt444Q1860616六角法兰面螺拴Hexangular bolt with flange445Q40206大垫圈Big washer4图4-5图4-5序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1BYDX3-5604210行李箱盖手动锁总成Trunk-lid-lock-manual-ASSY12Q32006六角法兰面螺母Nut23
21、BYDX3-5604220行李箱盖锁座总成Base-of-latch-a-trunk-lid-ASSY14Q2100620内六角花形圆柱头螺钉Bolt45Q40206平垫圈Plain washer106BYDX3-5605100行李箱盖运动铰链总成Mobile-hinge, cover trunk, ASSY17Q2150620内六角花形盘头螺钉Hexagon socket bolt with plate head 68BYDX3-5604135行李箱盖内板橡胶垫Rubber-bumper-trunk-lid49BYDX3-6004030行李箱盖左翻转机构总成Left motion actua
22、tor, trunk cover ASSY110BYDX3-6004040行李箱盖右翻转机构总成Right motion actuator, trunk cover ASSY111Q1840825TF2六角法兰面螺栓Hexangular bolt with flange1012Q40208大垫圈Big washer1613Q1860820六角法兰面螺栓Hexangular bolt with flange614BYDX3-5604134行李箱盖内板堵盖Plug, inside panel，cover trunk图4-6图4-6序号No.零件编号Part No.名 称Description数量Q
23、ty备注Rem中文Chinese英文English1Q1840825TF2六角法兰面螺栓Bolt2Q40208大垫圈Big washer3BYDX3-6004781行李箱机构左右拉丝卡座Base，l/r cable，COV trunk4BYDX3-6004550行李箱盖气动弹簧Gas spring, COV trunk5BYDX3-6004383行李箱盖左安装板Setting PAL,COV Trunk, L6BYDX3-6004922行李箱盖左右连接杆上螺栓Combination bolt, l/r connecting pal, COV Trunk7BYDX3-6004385行李箱盖安装板
24、定位销Anchor pin 1,Setting PAL,COV Trunk8BYDX3-6004387行李箱盖安装板定位销Anchor pin 2,Seting PAL,COV Trunk9BYDX3-6004921行李箱盖安装板定位销固定螺钉Combination bolt, Anchor pin ,Setting PAL,COV Trunk10Q2150620内六角花形盘头螺钉Bolt11BYDX3-6004393行李箱盖限位块焊接垫片Jointing washer, limitingblock, COV trunk图4-6图4-6序号No.零件编号Part No.名 称Descripti
25、on数量Qty备注Rem中文Chinese英文English12BYDX3-6004391行李箱盖安装板限位块Limit cushion，Setting pal，COV trunk13BYDX3-6004315左翻转机构底座塑料限位块Limit cushion，base，motion actuator ,l, COV trunk14BYDX3-6004570行李箱盖机构锁总成Actuator lock，COV trunk, ASSY15Q2150620内六角花形盘头螺钉Hexagon socket bolt with plate head16Q32206六角螺母锥形垫圈组合件Hexangula
26、r nut taper washer COMP17BYDX3-6004353行李箱盖主动臂限位轮Limit actuator，motion arm，COV trunk18Q1860635六角法兰面螺栓Bolt19Q32206六角螺母锥形垫圈组合件Hexangular nut taper washer COMP图4-7-1图4-7-1、图4-7-2序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1BYDX3-6002210车篷卷帘总成Coil shade, calash ,ASSY 12Q1860625六角法兰面螺栓Hexan
27、gular bolt with flange33BYDX3-6002192车篷内板后部小隔垫片Washer, back calash inside panel14BYDX3-6004650硬顶前锁紧机构总成Forward lock setup roof, ASSY 15Q2100616内六角花形圆柱头螺钉Hexagon socket bolt with column head116Q40106平垫圈Plain washer177BYDX3-6004710硬顶左前锁座总成Lock base, rear left, roof, ASSY18BYDX3-6004720硬顶右前锁座总成Lock bas
28、e, forward right, roof, ASSY19Q2100630内六角花形圆柱头螺钉Hexagon socket bolt with column head610BYDX3-6002191车篷前横护板下胶垫Rubber bumper of forwarddown-roof211BYDX3-6002751硬顶左前密封条Seal，forwardleft，roof112BYDX3-6002752硬顶右前密封条Seal，forwardright，roof1图4-7-2图4-8图4-8序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文En
29、glish1BYDX3-6001211车顶玻璃Glass, roof12BYDX3-6001214车顶后中胶条Seal, MID-BK, Roof13BYDX3-6001221车顶玻璃支承胶柱Supporting cushion, glass, roof8图4-9序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1BYDX3-6003211车篷后风窗玻璃Rear Windscreen of calash12BYDX3-6003314车篷后风窗玻璃下前胶条Front-nether seal, Rear Windscreen of
30、 calash13BYDX3-6003311车篷后风窗粘毡Felt 1, Rear Windscreen of calash54BYDX3-6003312车篷后风窗粘毡Felt 2, Rear Windscreen of calash25BYDX3-6003313车篷后风窗粘毡Felt 3, Rear Windscreen of calash16BYDX3-6001221车篷后风窗玻璃支承胶柱Transparent calotte， Rear Windscreen of calash8图4-9图4-10图4-10序号No.零件编号Part No.名 称Description数量Qty备注Rem
31、中文Chinese英文English1BYDX3-6002753硬顶中后部密封条Middle-rear seal, rigid roof12BYDX3-6002754硬顶后部密封条rear seal, rigid roof13BYDX3-5602112行李箱盖密封条Truck seal14Q2723513十字槽盘头自攻螺钉Self-drill bolt with cross socket & plate end45Q398B02A型通孔式嵌装塑料螺母Plastic nesting nut with hole, size A46BYDX3-6002755硬顶中后部密封条左端盖片Left end
32、cover, Middle-rear seal, rigid roof17BYDX3-6002756硬顶中后部密封条右端盖片Right end cover, Middle-rear seal, rigid roof1图4-11序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1BYDX3-6002050车篷翻转机构后翻盖总成Hinged rear parcel shelf side, roof, ASSY12BYDX3-6004010车篷左翻转机构总成Left motion setup , roof, ASSY13BYDX3-
33、6004020车篷右翻转机构总成Right motion setup, roof, ASSY14Q1860830六角法兰面螺栓Hexangular bolt with flange85Q40208大垫圈Big washer186Q1840825TF2六角头螺栓Bolt107BYDX3-6004912翻转机构与车篷连接调节垫片Washer 19图4-11图4-12图4-12序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1BYDX3-6004113车篷左翻转机构底座内板INR PAL, base, left motion se
34、tup, roof2BYDX3-6004923车篷翻转机构底座内板固定螺栓Fix bolt, INR PAL, base, left motion setup, roof3BYDX3-6004115翻转机构后翻盖复位弹簧卡簧Clip, Hinged rear parcel shelf4BYDX3-6004117翻转机构后翻盖复位弹簧垫片Washer, hinged rear parcel shelf5BYDX3-6004123车篷翻转机构底座小限位柱Small Limit FIXED, base, Motion setup , roof6BYDX3-6004125车篷翻转机构底座内板小限位柱S
35、mall limit fixed, INR PAL, base, motion setup, roof7BYDX3-6004137后侧翻盖拉丝固定座Fix base, cable, Hinged rear parcel shelf side8BYDX3-6004143车篷翻转机构主轴中间垫片Middle washer, shaft motion setup, roof9BYDX3-6004145车篷翻转机构后翻盖复位弹簧Spring, Hinged rear parcel shelf图4-12图4-12序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chi
36、nese英文English10BYDX3-6004147后翻盖复位弹簧连接簧片Connecting Reed, Hinged rear parcel shelf11BYDX3-6004151后翻盖左复位轮Left wheel， Hinged rear parcel shelf12BYDX3-6004157后翻盖左复位轮上连接杆Link， left wheel， hinged rear parcel shelf13BYDX3-6004161后翻盖复位轮上销轴PIN axle. Left Actuator， Hinged rear parcel shelf14BYDX3-6004163后翻盖复位轮上销轴卡簧Clip, PIN axle， left actuator， hinged rear parcel shelf15BYDX3-6004243顶篷前固定杆滑动块复位弹簧Spring，gliding block, FR fix bar, roof
