《汽车吊检查表.docx》由会员分享，可在线阅读，更多相关《汽车吊检查表.docx（8页珍藏版）》请在三一办公上搜索。
1、汽车吊检查表CONTRACTOR: 承包商: _ EQUIPMENT NUMBER: 设备号: _ MAKE: 制造: ENGINE: 发动机 HOUR METER:计时表: (S) INSPECTED AND SATISFACTORY（S) 经检验合格 Inspection Report HYDRAULIC R/T CRANES 轮式液压起重机 BSF CONTROL NO. BSF序号: _ REG#: 牌照: _ DATE: 日期: _ MODEL: 型号 :_ S/N: MODEL: 型号: _ S/N: ODOMETER:里程表: (X) REQUIRES RECHECK AND O
2、R REPAIR（X) 要求重检和或维修 (R) PREPAIRED AND OR ADJUSTED （R) 修理和或调整 OPERATORS CAB操作室 Step, Door Handle, Latch踏板，门拉手，插 销 Seat, Seatbelt, Cleanliness座椅，安全带，室 内卫生 Windshield, Cab Glass风挡玻璃，驾驶室玻 璃 Windshield Wiper, Washer雨刮器，喷水器 Fan ( Air Circulation) 风扇( 通风) Sun Visor 遮阳板 Speedometer里程表 Tachometer转速计 Audio,
3、Visual Alarms声音，视觉报警器 Indicators, Gauges指示器，量表 Switches开关 Mirrors, Rear, Left, Right左右后视镜。 ELECTRICAL SYSTEM电气系统 Headlights, Low / High Beam大灯。高位， 低位 Signal / Hazard Lights, Front Rear信号、应 急灯。前后 Tail Lights, Brake Lights尾灯，刹车灯 Horn喇叭 Back Up Lights / Alarm倒车灯，报警器 Flashing Light, Cab Mounted闪光灯，驾驶 室安
4、装支架 Electrical System Wiring电气系统电线 Batteries, Covers, Hold Downs蓄电池。盖 子，固定夹子 Battery Terminals, Cables蓄电池终端，电缆 S S R R X X ENGINE发动机 Oil Leaks漏油 Coolant Leaks冷却剂泄漏 Fuel Leaks燃料泄漏 Fan, Guards, Belts风扇。护罩，皮带 Abnormal Exhaust Smoke异常排烟 Exhaust System, Leaks, Silencer排烟系统。 泄漏，消音器 Radiator, Leaks, Cap, G
5、asket散热器。泄 漏，盖子，密封垫 OPERATOR STATION操作室 Throttle Control油门控制踏板 Brake Pedal刹车踏板 Transmission Controls变速系统控制 Outrigger Controls叉架控制 Machine Level Indicator机器水平仪 Boom Hoist Control吊升降控制 Angle / Range Load Chart角度、范围荷载图 Boom Angle indicator吊臂角度指示器 Main Winch Control主绞盘机控制 Auxiliary Winch Control副绞盘机控制 B
6、oom Extension Control吊臂伸缩控制 Swing & Brake Controls旋转，闸控制 Cab Swing Safety Lock驾驶室旋转安全锁 360 Degree Swing Lock 360度旋转锁 Rear Axle Oscillation Stop Locks后轮轴振动 止动锁 DRIVE TRAIN驱动装置 Front Axle Housing, Mounting Bolts前轮 轴。机架，固定螺栓 Steering Knuckles, Hubs, Spindles球头，轴 套，心轴 Differential Planetaries, Seals, Le
7、aks差速行 星齿轮。密封件，漏油 Trunnion Bearings, Mounting Bolts耳轴承， 固定螺栓 Rear Axle Housing, Mounting Bolts后轮 轴。机架，固定螺栓 Steering Knuckles, Hubs, Spindles球头，轴 套，心轴 Differential Planetaries, Seals, Leaks差速行 星齿轮。密封件，漏油 Trunnion Bearings, Mounting Bolts耳轴承， 固定螺栓 Drives Shafts, Front, Rear前后驱动轴 Transmission, Mounting
8、s, Seals, Leaks传动 装置。密封件，泄漏 S R X S R X S R X Transfer Case, Mountings, Seals, Leaks分动 箱。固定装置。密封件，泄漏 Torque Converter, Seal, Leaks液力变矩器， 密封，漏油 Torque Converter Drive Shaft液力变矩器， 驱动轴 STEERING SYSTEM方向系统 Steering Wheel, Linkage方向盘，联接杆 Orbital Pump, Leaks轨道泵，泄漏 Control Valve, Steering Box, Oil Leaks控制
9、阀，转向机。漏油 Follow Up Linkage随动联接 Steering Cylinders, Oil Leaks转向助力缸 BRAKE SYSTEM刹车系统 Air 气刹 Hydraulic 液压 Brake Chambers, Linings 气制动室，衬套 Rotors, Pads, Calipers转子，衬垫，卡钳 Brake Tubes, Hoses, Front, Rear前后刹车 管，软管 Brake Test,刹车测试 Parking Brake, Test手刹测试 UPPER STRUCTURE上方结构 Boom Pedestal, Mounting bolts吊臂基架
10、，固 定螺栓 Counterweight Mounting Bolts平衡锤固定螺 栓 Main & Auxiliary Winch Mountings主、副 绞盘装置 Swing Drive Motor & Brake, Noise, Leaks旋 转驱动马达及制动。噪声，漏油 Hydraulic Hoses, Connections, Leaks液压软 管，连接件，漏油 Compressed Air Lines, Connections, Leaks压缩空气 管，连接件，漏油 Swing Gear, Bearing & Pinion旋转齿轮。轴 承及小齿轮 BOOM ASSEMBLY吊臂总
11、成 Boom Angle Indicator吊臂角度指示器 Base Section Inspection底座检查 Mounting Pins, Locks, Grease Fittings固定 销，锁，黄油嘴 Intermediate Section Inspections中间部分检 查 Tip Section Inspection顶端部分检查 S R X S R X S R X S R X Inner Boom slides吊臂内部滑动 Outer Boom Slides吊臂外部滑动 Boom Internal Cables, Chains, Sheaves吊臂 内部电缆，锁链，滑轮 Hy
12、draulic Hoses, Connections, Leaks液压软 管，连接件。泄漏 Point Sheaves点滑轮 Load Block Sheaves, SWL载荷滑轮车。滑 轮。安全工作负荷 Load Block, Hook, Latch, SWL载荷滑轮 车。吊钩，插销。安全工作负荷 Wire Rope Condition, Anchorages钢丝绳， 连接件，固定 Headache Ball, Hook, Latch, SWL。钢丝绳 葫芦。吊钩，锁，安全荷载 CRANE HYDRAULICS吊机液压系统 Boom Lift Cylinders, Leaks吊臂升降液压 缸
13、。漏油 Counterbalance Valves, Leaks平衡阀漏油 Boom Extension Cylinder, Leaks吊臂伸缩 液压缸。漏油 Counterbalance Valve, Leaks平衡阀漏油 Mounting Pins, Locks, Grease Fittings固定 销，锁，黄油嘴 Hydraulic Tubes, Hoses, Connections, Leaks液压管， 软管，连接件漏油 Outrigger Cylinders, Rear, Leaks后叉架。液 压缸漏油， Outrigger Cylinders, Front, Leaks前叉架液压
14、缸漏油。 Outrigger Counterbalance Valves, Leaks叉架 平衡阀泄漏 Mounting Pins, Locks, Grease Fittings固定 销，锁黄油嘴 Hydraulic Tubes, Hoses, Connections, Leaks液压管， 软管，连接件。泄漏 Main System主液压系统 Hydraulic Pump, Leaks, Noise液压泵。泄 漏，噪声 Hydraulic Pump Manual Disconnect液压泵手 动分离 Control Valves, Oil Leaks, Hoses控制阀。漏 油软管 Hydra
15、ulic Tank, Oil Leaks, Cap, Seals液压 缸。漏油，盖子，密封圈 Tank Mountings, Straps缸体固定件，固定夹 子 S R X Hoist Motors卷杨机马达 Main Hoist Motor, Brakes, Noise, Leaks主卷 杨机马达。刹车，噪声，泄漏 Auxiliary Hoist Motor, Brakes, Noise, Leaks副卷杨机 马达。刹车，噪声，泄漏 Hydraulic Tubes, Hoses, Connections, Leaks液压管， 软管，连接件，泄漏 Friction drive clutch a
16、nd brakes盘式摩擦离 合器及刹车 Swivel Joint, Leaks转节泄漏 AIR SYSTEM空气系统 Compressor, Oil Leaks, Pumping Oil压缩 机，漏油， Air Tanks, Mountings, Safety Valve气缸，固 定架，安全阀 Tubes, Hoses, Drain Valves气压管，软管， 排气阀 FUEL TANK燃料罐 Leaks, Cap, Gasket泄漏，盖子，密封垫 Mounting Brackets, Straps固定垫，固定夹子 Fuel Lines, Connections, Leaks燃料管，连接 件
17、 SAFETY安全 Engine Emergency Shutdown Switch发动机 紧急关闭开关 Outrigger Pads叉架衬垫 Load Moment Indicator负荷瞬间指示器 LMI Manual手动负荷瞬间指示 Operators Manual操作员手册 Operators Daily Log Book操作员日记薄 Anti Two Block Alarm / Cut out限位警报/切 断 Over Boom Alarm / Cut out超高警报/切断 Over Hoist Alarm / Cut out超重警报/切断 Travel, Swing Audio A
18、larms行进旋转音频警 报 Fire Extinguisher, Capacity, Date Charged灭 火器，容量，更换日期 ENVIRONMENTAL环保 Emergency Spill Kit应急油污处理工具 ACCESSORIES附件 Jib Boom 悬臂 Boom Point Extension吊臂伸缩 S R X S R X S R X S R X S R X Pendant Lines下垂线 TIRES轮胎 Front / Rear, Condition,前后轮胎状况 Front / Rear, matched前后轮胎对称 Wheels, Rims, Lock Rings车轮，轮圈，装 饰盖 Mounting Nuts, Studs固定螺母,螺栓 PLY S R X TYPE TIRES SIZE PERCENTAGE LEFT FRONT前 Comments:意见 Use additional Pages if necessary to describe findings indicated in “X” and “R” check boxes Date Inspection Completed: 检查日期： Contractor Rep:检查人签字： Badge #:胸卡号：
