《服装疵点描写中英文.doc》由会员分享，可在线阅读，更多相关《服装疵点描写中英文.doc（23页珍藏版）》请在三一办公上搜索。
1、5. Defect List for Garment5.1 Woven Garment: Code Defect description Chinese nameCritical MajorMinor Material DefectsWG001Weaving faults - (Broken yarn)布疵 (断纱)xWG002Weaving faults - (Missed yarn)布疵 (缺纱)xWG003Weaving faults - (Coarse yarn)布疵 (粗纱)xxWG004Weaving faults - (Slub)布疵 (大肚纱)xWG005Weaving fau
2、lts - (Neps)布疵 (棉结)xWG006Weaving faults - (Colour dye bars)布疵 (染色横条)xWG007Weaving faults - (Colour stripes)布疵 (染色竖条)xWG008Weaving faults - (Thick place)布疵 (密路)xWG009Weaving faults - (Thin place)布疵 (稀路)xWG010Weaving faults - (Thick bar)布疵 (厚档)xWG011Weaving faults - (Thin bar)布疵 (薄档)xWG012Holes破洞xWG01
3、3Fabric torn布烂xWG014Permanent creases lines in fabric死皱痕xWG015Permanent fold lines in fabric死折痕x CleanlinessWG051Stain污渍xxWG052Oil spots油点xxWG053Oil stain油渍xxWG054Water spots水点xWG055Water stain水渍xxWG056Rust stain锈渍xWG057Pen mark钢(圆)笔痕xWG058Pencil mark铅笔痕xxWG059Chalk mark粉笔痕xxWG060Glue stain胶水渍xxWG06
4、1Glue mark胶水痕xxWG062Untrimmed thread ends线头未剪清xWG063Loose thread松缝线xWG064Dust fibers attached on fabric surface脏污纤维附在织物表面xWG065Loose fibers attached on fabric surface松散纤维附在织物表面x AppearanceWG101Colour shade variation色差xxWG102Colour off tone脱色xWG103Glaze起镜 (反光)xWG104Poor ironing熨烫不良 xWG105Creases mark
5、皱痕xWG106Wrinkle mark起皱xWG107Fold mark折痕xxWG108Unmatched checks不对格xxWG109Unmatched stripes不对条xxWG110Sewn in wrong fabric direction布纹用错xWG111Sewn in wrong fabric side布正反面用错xWG112Washing mark洗水痕xxWG113Uneven washing effect洗水不良xWG114Burned烧毛过度xWG115Scorched焦痕xWG116Over pressed (seam impressions)熨烫过度xWG1
6、17Stretched shape due to pressing熨烫不良 (伸长)xWG118Distorted shape due to pressing熨烫变形xWG119Bubbles due to improper fusing里衬不良造成起泡x Stitching DefectsWG151Broken stitches断线xWG152Skipped stitches跳线xxWG153Run-off stitching线落坑xxWG154Uneven stitching线迹不匀xxWG155Irregular stitching线迹不规则xxWG156Wavy stitching线迹
7、起波浪xxWG157Insecured back stitching回针不良xWG158Loose stitch tension线迹张力松xxWG159Uneven stitch tension线迹张力不匀xxWG160Uneven stitch density线迹密度不匀xxWG161Missed stitching漏车缝xWG162Missed bar tack欠打枣xWG163Unmatched join stitching驳线不良xxWG164Missed sewing operation漏车缝工序xWG165Needle chewing针痕xx Seaming DefectsWG20
8、1Open seam开缝xWG202Puckered seam缝起皱xxWG203Pleated seam缝打折xWG204Twisted seam扭缝xWG205Puckering起皱xxWG206Frayed edges散口xWG207Folded seam车缝折叠xWG208Seams folded opposite to specify direction缝折向错误xWG209Unaligned seam缝不对称xWG210Unmatched seam缝不相配xWG211Uneven pleats length折长度不对称xxWG212Uneven darts width摺宽不对称xx
9、WG213Misplaced bar tacks错打枣位置 xWG214Uneven seam length缝长不对称xx CollarWG241Uneven collar points领尖不对称xWG242Mis-shaped collar points错领尖xWG243Unbalanced collar领型不对称xWG244Overlapping collar领重叠太多xWG245Bubble in collar fall上级领起泡xWG246Bubble in collar stand下级领起泡xWG247Uneven collar end下级领尖不对称x Front PlacketWG
10、271Uneven placket width门襟宽不对称xxWG272Incorrect placket width门襟宽不对xWG273Uneven placket length门襟长不对称xxWG274Visible under placket露底襟xx Button & Button HoleWG301Missed button欠钮xWG302Broken button烂钮xWG303Insecured button stitching钮扣车线不牢xWG304Wrong button错钮xWG305Omitted button hole欠钮门xWG306Incomplete stitc
11、hing车缝不全xWG307Uncut button hole钮门未开xWG308Unaligned button & button hole钮与钮门位置不相对xxWG309Misplaced button & button hole钮与钮门错位xxWG310Button stitch not properly locked 钮线打结不良x Sleeve & CuffWG341Uneven sleeve length袖长不对称xxWG342Uneven sleeve placket length袖口襟长度不对称xxWG343Uneven sleeve placket width袖口襟宽度不对称
12、xxWG344Notches exposed at sleeve slit袖叉定位口外露xWG345Wrong attach of sleeve lining袖里不对xWG346Uneven cuff width袖口宽不对称xxWG347Uneven cuff height袖口长不对称xx Front / Back Yoke / ShoulderWG381Excess gatherings at yoke seam担干多余褶位xxWG382Unmatched seams at armhole袖窿缝不对称xxWG383Improper gatherings at sleeve cap袖山打褶不对
13、称xx Pocket & Pocket FlapWG401Unaligned front pockets(Hi-Low pocket)高低袋xxWG402Slanted pocket袋斜xxWG403Excess tightness of pocket袋口太紧xxWG404Excess fullness of pocket袋口太松xxWG405Pocket cloth not smooth when bar tacking袋布打枣口不平顺xxWG406Twisted pocket cloth袋布扭曲xWG407Poorly shaped pocket袋形不好xWG408Poorly shape
14、d pocket corner袋角形不好xWG409Misplaced pocket position袋位不正xxWG410Incorrect pocket position错袋位xWG411Exposing pocket corner袋角外露xWG412Incorrect position of pocket flap袋盖位不对x HemWG451Torn at rib烂罗纹xWG452Holes at rib罗纹破洞xWG453Uneven hem下摆不对称xxWG454Twisted hem下摆扭曲xWG455Wavy hem下摆起波浪xx Lining WG481Lining too
15、short or too long里料太短或太长xWG482Puckering at lining seam里料缝口起皱xxWG483Twisted lining里料扭曲x Waistband & Belt LoopWG501Uneven waistband(Hi-Low waistband)高低腰带xxWG502Poor waistband finishing腰带成形不良xxWG503Uneven belt loop腰耳仔不对称xxWG504Improper position of belt loop耳仔错位xWG505Missed belt loop欠耳仔x FlyWG531Uneven
16、fly width钮牌宽不匀xWG532Curved fly edge钮牌边弯曲xWG533Exposed zipper tape when fly is closed露拉链x LegWG571Twisted leg扭脚xWG572Uneven leg长短脚xWG573Side seam turned wrongly侧缝方向错xWG574Irregular hem width脚口宽不对称xx EmbroideryWG601Missed embroidery欠绣花xWG602Misplaced embroidery绣花错位xWG603Broken embroidery stitches断绣线xW
17、G604Incorrect embroidery stitch density绣线密度不对xWG605Uneven embroidery stitching绣线不均xxWG606Colour off shade or not as specified绣线脱色xWG607Wrong embroidery错绣花 x Printing DefectsWG641Missed printing欠印花xWG642Misplaced printing印花错位xWG643Printing faults - (Printing stain/color smear)印疵 (印污迹)xxWG644Printing
18、faults - (Off printing/ out of register )印疵 (印花移位)xWG645Colour off shade or not as specified印花脱色xWG646Wrong printing错印花x Labels & HangtagsWG681Missed label欠商标xWG682Missed hangtag欠挂牌xWG683Wrong label错商标xWG684Wrong hangtag错挂牌xWG685Label insecurely stitched商标车缝不牢xWG686Label folded by stitching商标车折xxWG6
19、87Part of label sewn inside seam商标部份被车入缝xWG688Label sewn inverted(Label up-side-down)商标颠倒xWG689Label sewn reversed(Label up-side-down)商标车反x AccessoriesWG701Scratches 挂花xxWG702Poor plating 电镀不良xWG703Sharp points 利点xWG704Sharp edges 利边xWG705Rust 生锈xWG706Wrong accessories错附件xWG707Colour discharged 脱色xW
20、G708Malfunction of zipper拉链失灵xWG709Zipper slider running not smoothly拉链不顺畅xxWG710Missed zipper teeth拉链掉齿xWG711Missed zipper puller掉拉链头xWG712Wavy zipper拉链起波xxWG713Poor setting of zipper拉链安装不良xWG715Zipper tape too close to fly seam affecting zipper function拉链带近骨口影响功能xWG716Detached snap按钮掉xWG717Detache
21、d rivet铆钉掉xWG718Detached stud按钮掉xWG719Snap too tight to close or open按钮开关太紧xxWG720Snap too loose to close or open按钮开关太松xxWG721Fabric torn around snaps按钮位置布烂xWG722Missed shoulder pads欠肩衬xWG723Misplaced shoulder pads肩衬错位xxWG724Missed velcro tapes欠魔术带xWG725Misplaced velcro tapes魔术带错位xx Packing DefectsW
22、G751Wrong folding size折叠尺寸不对xWG752Wrong folding method折叠方法不对xWG753Wrong hangtag挂牌错xWG754Wrong tissue paper垫纸用错xWG755Missed hangtag欠挂牌xWG756Missed tissue paper欠垫纸xWG757Missed Silica gel欠防潮剂xWG758Missed spare button欠备用钮xWG759Polybag torn胶袋破x Miscellaneous DefectsWG801Wrong size label错尺码商标xWG802Odor异味x
23、WG803Mildew发霉xWG804Wet item受潮xW805Damp item受湿x 5.2 Knitted GarmentCode Defect description Chinese nameCriticalMajorMinor Material DefectsKG001Knitting faults - (Broken yarn)布疵（断纱）xKG002Knitting faults - (Uneven knitting yarn)布疵（编织纱线不匀）xKG003Knitting faults - (Coarse yarn)布疵（粗纱）xxKG004Knitting faults
24、 - (Slub)布疵（大肚纱）xKG005Knitting faults - (Neps)布疵（棉结）xKG006Knitting faults - (Colour yarn)布疵（色纱）xKG007Knitting faults - (Dye bars)布疵（染色横条）xKG008Knitting faults - (Stripes)布疵（染色竖条）xKG009Knitting faults - (Run stitches+B55)布疵（漏针）xKG010Knitting faults - (Needle line)布疵（针路)xKG011Knitting faults - (Ladder
25、ing)布疵（漏针）xKG012Knitting faults - (Drop stitches)布疵（漏针）xKG013Knitting faults - (Loose stitches)布疵（松针）xKG014Holes破洞xKG015Fabric torn布烂xKG016Permanent creases lines in fabric死皱痕xKG017Permanent fold lines in fabric死折痕x CleanlinesKG051Stain污渍xxKG052Oil spots油点xxKG053Oil stain油渍xxKG054Water spots水点xKG055
26、Water stain水渍xxKG056Rust stain锈渍xKG057Pen mark钢(圆)笔痕xKG058Pencil mark铅笔痕xxKG059Chalk mark粉笔痕xKG060Glue stain胶水渍xxKG061Glue mark胶水痕xxKG062Untrimmed thread ends线头未剪清xKG063Loose thread松缝线xKG064Dust fibers attached on fabric surface脏污纤维附在织物表面xKG065Loose fibers attached on fabric surface松散纤维附在织物表面x Appea
27、ranceKG101Colour shade variation色差xxKG102Colour off tone脱色xKG103Glaze起镜 (反光)xKG104Poor ironing熨烫不良 xKG105Creases mark皱痕xKG106Wrinkle mark起皱xKG107Fold mark折痕xxKG108Unmatched checks不对格xxKG109Unmatched stripes不对条xxKG110Sewn in wrong fabric direction布纹用错xKG111Sewn in wrong fabric side布正反面用错xKG112Washing
28、 mark洗水痕xxKG113Uneven washing effect洗水不良xKG114Burned烧毛过度xKG115Scorched焦痕xKG116Over pressed(seam impressions)熨烫过度xKG117Stretched shape due to pressing熨烫不良 (伸长)xKG118Distorted shape due to pressing熨烫变形xKG119Bubbles due to improper fusing里衬不良造成起泡x Stitching DefectsKG151Broken stitches断线xKG152Skipped st
29、itches跳线xxKG153Run-off stitching线落坑xxKG154Uneven stitching线迹不匀xxKG155Irregular stitching线迹不规则xxKG156Wavy stitching线迹起波浪xxKG157Insecured back stitching回针不良xKG158Loose stitch tension线迹张力松xxKG159Uneven stitch tension线迹张力不匀xxKG160Uneven stitch density线迹密度不匀xxKG161Missed stitching漏车缝xKG162Missed bar tack
30、欠打枣xKG163Unmatched join stitching驳线不良xxKG164Missed sewing operation漏车缝工序xKG165Needle chewing针痕xx Seaming DefectsKG201Open seam开缝xKG202Puckered seam缝起皱xxKG203Pleated seam缝打折xxKG204Twisted seam扭缝xKG205Puckering起皱xxKG206Frayed edges散口xKG207Folded seam车缝折叠xKG208Seams folded opposite to specify direction
31、缝折向错误xKG209Unaligned seam缝不对称xKG210Unmatched seam缝不相配xKG211Uneven pleats length折长度不对称xxKG212Uneven darts width摺宽不对称xxKG213Misplaced bar tacks错打枣位置 xKG214Uneven seam length缝长不对称xxKG215Linking seam cannot stand for stretch链缝拉伸强度不够x Collar / NeckKG251Collar shape not as approved领型不对xKG252Little recover
32、y or no elasticity at neck领松紧不良xKG253Neck opening too small for wearing领口太小x Button & Button HoleKG301Missed button欠钮xKG302Broken button烂钮xKG303Insecured button stitching钮扣车线不牢xKG304Wrong button错钮xKG305Omitted button hole欠钮门xKG306Incomplete stitching车缝不全xKG307Uncut button hole钮门未开xKG308Unaligned but
33、ton & button hole钮与钮门位置不相对xxKG309Misplaced button & button hole钮与钮门错位xxKG310Button stitch not properly locked 钮线打结不良x Sleeve & CuffKG351Uneven sleeve length袖长不对称xxKG352Notches exposed at sleeve slit袖叉定位口外露xKG353Wrong attach of sleeve lining袖里不对xKG354Uneven cuff width袖口宽不对称xxKG355Uneven cuff height袖口
34、长不对称xx BodyKG401Excess gatherings at yoke seam担干多余褶位xxKG402Unmatched seams at armhole袖窿缝不对称xxKG403Improper gatherings at sleeve cap袖山打褶不对称xxKG404Deformed shape变形x Pocket & Pocket FlapKG451Unaligned front pockets(Hi-Low pocket)高低袋xxKG452Slanted pocket袋斜xxKG453Excess tightness of pocket袋口太紧xxKG454Excess fullness of pocket袋口太松xxKG455Pocket cloth not smooth when bar tacking袋布打枣口不平顺xxKG456Twisted pocket cloth袋布扭曲xKG457Poorly shaped pocket袋形不好xKG458Poorly shaped pocket corner袋角形不好xKG459Misplaced pocket position袋位不正xxKG460Incorrect pocket position错袋位xK
