《CRTSI无砟轨道施工时常见缺失与注意事项.ppt》由会员分享，可在线阅读，更多相关《CRTSI无砟轨道施工时常见缺失与注意事项.ppt（32页珍藏版）》请在三一办公上搜索。
1、Precautions on common defects of CRTS-I Non-Ballasted track construction,成渝客运专线监理三标,CRTS I 型双块式无砟轨道施工常见缺失与注意事项,1,Basic concept must keep in mind必须常记在心的基本观念,Accuracy/Tolerance requirement:mm evenmm施工精度与误差要求：毫米甚至毫米以下，失之毫厘差之千里3.Working and inspecting in details细化施工工艺与检查：多检查并及时整改才能少返工。魔鬼藏在细节里Standardize
2、d construction procedures标准化施工工序：谋定而后动，一次到位一步错全盘皆输,2,Protection on CPIII Bench marksCPIII 网控制点的保护,No protection cap applied and Mortar clued onto bolt thread预埋的CPIII 螺栓孔未加防护盖,水泥砂浆粘附孔内螺纹,3,Protection on CPIII Bench marksCPIII 网控制点的保护,No clearance between CPIII pole and backfilling layerCPIII 控制点立柱与路基
3、回填材料之间,未保持净空,4,Protection on CPIII Bench marksCPIII 网控制点的保护,Scratch found on the CPIII poleCPIII 控制点立柱表面存在碰撞痕迹,5,6,Protection on CPIII Bench marksCPIII 网控制点的保护,Out forcing on the CPIII pole施加外力在CPIII 控制点立柱上,Preparation and takeover the Deck furniture桥面系附属构件的准备与移交工作,7,8,Preparation and takeover the D
4、eck furniture桥面系附属构件的准备与移交工作,OCS foundation was cast in two pieces接触网基础被分割为两次浇筑，非一体成型浇筑,9,Preparation and takeover the Deck furniture桥面系附属构件的准备与移交工作,Expansion joint seams of precast parapet were not match to the inner wall of CIS parapet，then the joint seams broken due to lack of free space for the
5、girder deflection现浇A墙的伸缩缝与预制遮板的伸缩缝未对齐，因梁体挠度变化造成A墙与遮板无伸缩空间而积压破损,Multi construction properties arrangement同一施工作业面多种作业项目与工序的安排,10,Roughness treatment on Bridge deck桥面的凿毛工作,11,Roughness treatment on Bridge deck桥面的凿毛工作,12,Roughness treatment on Bridge deck桥面的凿毛工作,13,Tool rail and steel frame轨排框架与工具轨,14,T
6、ool rail and steel frame轨排框架与工具轨,15,Expansion joint seal and steel channel installation伸缩缝耐候型钢与橡胶密封带的安装,16,Expansion joint and steel channel installation伸缩缝耐候型钢与橡胶密封带的安装,17,Expansion joint and steel channel installation伸缩缝耐候型钢与橡胶密封带的安装,18,Expansion joint and steel channel installation伸缩缝耐候型钢与橡胶密封带的安
7、装,Incompletely inserted expansion joint seal伸缩缝橡胶密封的嵌条，未完全嵌入耐候型钢的卡槽内,19,Geotextile installation of Track slab construction无砟轨道轨道板施工-土工布隔离层安装,Late removed fixing nail串钉拔除时机太晚,20,Rebar installation of Track slab construction无砟轨道轨道板施工-钢筋安装,21,Rebar installation of Track slab construction无砟轨道轨道板施工-钢筋安装,
8、Defective insulation绝缘不良,22,Rebar installation of Track slab construction无砟轨道轨道板施工-钢筋安装,23,Concrete curing of Track slab construction无砟轨道轨道板施工-混凝土养护,Lack of continue moistening未保持混凝土湿润的连续性,24,25,Suggestion of construction optimization施工优化的建议-桥面板凿毛时的防尘,Install cover and vacuum on the concrete scrubbe
9、r to prevent dust pollution安装防护罩及吸尘机在凿毛机上，及时将凿毛时的尘土收集在吸尘机的集尘袋内，防止凿毛时的尘土飞扬,Suggestion of construction optimization施工优化的建议-底座板施工,26,27,Suggestion of construction optimization施工优化的建议-轨道板钢筋问题,Designed upper layer and lower layer rebar were in same size and length,the hooks joint together became complica
10、ted at corner.It causing different concrete cover on side and the rebar cage will not be quadrated shape.Especially 4 hooks fixed at corners.设计钢筋笼上下层钢筋长度相同，因此在轨道板四周的立面弯钩都会出现互相干扰，特别是四个角落钢筋弯钩的绑扎变得极其复杂，造成同一根钢筋有不同的保护层的现象；且钢筋笼整体无法形成方正的主体,Suggestion of construction optimization施工优化的建议-轨道板钢筋调整方案-1,28,Modif
11、y all the rebar to two different lengths as upper layer rebar longer than lower layer 统一将钢筋笼上下层钢筋长度调整成上层筋较下层筋长，以上包下的形式形成箍,Plan view 平面效果模拟,Vertical view 立面效果模拟,3D view 立体效果模拟,Longitudinal bar 纵向钢筋,Horizontal bar 横向钢筋,Suggestion of construction optimization施工优化的建议-轨道板钢筋调整方案-2,29,Combine the upper and
12、 lower layer horizontal bar to be closed stirrup if there is no problem with the electricity insulation between each single one of them and agreed by designer.It could save huge cost on material and installation请设计单位研究，在无单一组上下层钢筋绝缘必要性的前提下，将横向钢筋笼上下层改为由单一根钢筋弯折成的闭合箍，可省下许多成本,Fix the overlap joint by two
13、 insulation clips 闭合搭接处使用两个绝缘卡夹固定,Three hooks remained at corners from four轨道板各个角落的弯钩可因此由四个减少到三个,30,Suggestion of construction optimization施工优化的建议-防水层基底-底座板根部,Make footing corner as smooth curve prevent void kept under waterproofing将底座板的根部做成圆弧可有效保证防水层密贴避免防水层下气泡,Suggestion of construction optimization施工优化的建议-防水层基底-底座板模板,31,谢谢聆听敬请指教,hanks for your attention,32,CYPDL Supervision Lot 3成渝客运专线监理3标-高生华,
