《CACT 消防安全作业规范培训.ppt》由会员分享，可在线阅读，更多相关《CACT 消防安全作业规范培训.ppt（38页珍藏版）》请在三一办公上搜索。
1、Fire Prevention and Protection SWPP Training CACT 消防安全作业规范培训,This SWPP Covers Two Aspects:How to prevent a fire from occurring.What protections are in place to control a fire.本作业规范讲了以下两个方面内容:1.如何预防火灾.2.火灾的监测和控制.,General Fire Prevention Practices 预防火灾 的一般要求,Smoking 吸 烟 at Designated area 指定吸烟区,Genera
2、l Fire Prevention Practices 预防火灾 的一般要求,HousekeepingJunction/Switch Box-Properly Closed接线盒/开关盒-拧紧螺丝,封好 Flammable Leaks-Clean Immediately 易燃品泄露-立即清理 Open Drains-Maintain Water Seal地漏-保持水密封,General Fire Prevention Practices 预防火灾 的一般要求,Storage of Flammables易燃品的存放,SEAL,LABLE,密封,标签,阴凉,通风,Cool,shaded,Away
3、From 远离,Ignition Source火源,Process生产设备,Oxidizer氧化物,Accommodation,生活区,Normal Operation日 常 作 业,General Fire Prevention Practices 预防火灾 的一般要求,Storage of Explosive Materials爆炸品的存放,Be Stored on Quick-release Trays on Platform Edge,存放在平台的边缘,General Fire Prevention Practices 预防火灾 的一般要求,Install/Replace Electr
4、ical Components安装/更换电器设备Check the electrical classification when install/replace electrical components.安装/更换电器设备时注意检查设备的电器安全级别是否满足安装区域对电器的安全级别的要求.,UL Class 1,Division 1,General Fire Prevention Practices 预防火灾 的一般要求,Non-explosive Electrical Devices非防爆电器,Not to be used in hazardous classified areas or
5、go through hot work procedure在有电器安全级别要求的区域使用须申领“使用电器作业许可证”,General Fire Prevention Practices 预防火灾 的一般要求,Clothes Driers 洗衣房烘干机Clean Filter Daily 每日清洁过滤网Do Not Dry Oil-soaked Cloth/Mop 不要烘干油抹布 Clean Oil/Chemical on Coverall before Placing into Dry Machine 工衣上的油污/化学药剂洗干净后再烘干 Check the Lighters in Pocke
6、t 检查衣兜中的打火机 Remove Clothes from Drier when it Stops 烘干机 停止后立即取出衣物,General Fire Prevention Practices 预防火灾 的一般要求,Kitchen 厨 房Powered Stoves shall not be left unattended.厨师不能在炉子通电 的情况下离开.,Fire Prevention Through Operations 生产作业中如何防火,Taking Samples 取 样Control the Flow Standby the Shut off Valve.取样时不要离开关断
7、阀门.Prevent Accidental Release Plug All Open-end Connections or Sample Draws Used Less Than Once Per Week.用堵头堵住所有接头的开口端及使用频率少于一周次的取样点.Prevent Static Electricity Metal Bucket,Bonded to Sample Connection.防静电火花 用金属桶,桶与取样点用导线连好.,Fire Prevention Through Operations 生产作业中如何防火,Critical Process Equipment 关键生产
8、设备Maintenance/Facility Group:-Identify Critical Equipment 确定关键生产设备-Develop/Implement Inspection Program 制订/实施定期检查计划,Fire Prevention Through Operations 生产作业中如何防火,Hot Surfaces 高温管线/设备-Rarely at Temperatures Sufficient to Ignite Flammable Mixture.很少会达到能引燃燃气的温度.-Many are Hot Enough to Ignite Oil,Lint,Ra
9、gs,Paper and even Wood.很多足以引燃 油,抹布,纸甚至木材.-Exposed surfaces in excess of 60C shall be insulated.有可能接触到液体/固体可燃物,表面温度超过 60 C的管线/设备应加隔热层.,Fire Prevention Through Operations 生产作业中如何防火,Pumps/Engines 泵/内燃机-Frequently Inspect Seal,Gland,Gasket leakage and General Cleanliness of Pump.日常检查泵的密封和清洁.-Annually In
10、spect and Ensure No Damage due Vibration.年度检查确保无振动引起的损坏.-Check Motors for Overheating,Sparking,Switches,Overload Protection and Wiring.马达应检查过热,火花,开关,过载保护及接线.-Exhaust on Combustible Engine No Contact by Lube Oil or other Combustible Materials.内燃机尾气排放管不要接触润滑油或其它可燃物.,Fire Prevention Through Operations
11、生产作业中如何防火,Structures 结构-Structures Containing Pumps/Piping etc.may possibly Leak Flammables should be well Ventilated.有可能造成泄露的泵,管线等生产设备所在区域应 保持良好通风.-Any Enclosed Spaces(Platform Legs,Potable Water Tanks,Water/Air Systems)may Contain Explosive Mixture,Gas Test must be Performed before Cutting/Welding
12、 on or next to Enclosed Spaces.海上任何管线/罐内都有可能有燃气,在任何管线/罐上热割或焊接都应先对内部进行燃气检测.,Fire Prevention Through Operations 生产作业中如何防火,Safety Devices 安全保护装置 All Very Important for Fire Prevention.Inspection/Maintenance shall be Performed no less than Once Per Year.对防火举足轻重,检查/保养至少一年一次.,PSV 压力安全阀,Breather Valve 通气阀,
13、Regulators减压阀,Over speed Trips 过速关断,ESD 紧急关断,Fire Prevention Through Operations 生产作业中如何防火,Safety Devices 安全保护装置,PSV压力安全阀,Lock or Seal上锁或铅封,Open Position,全开状态,Fire Prevention Through Operations 生产作业中如何防火,Flares 火焰,Be careful,air may get into the fare line and cause explosion!,不要让空气进入具有火焰的管道,引起爆炸!,Fir
14、e Prevention Through Operations 生产作业中如何防火,Flares 火焰,Manual Lighting Flare is Prohibited严禁作业人员携带火源,Fire Prevention Through Operations 生产作业中如何防火,Draining,Vapor Freeing,Purging Procedures 排空,清除蒸汽,惰性气体置换程序,Its Hard to Remember!太复杂,记不住!,No Need to,Review when Perform the Work.不必牢记,用着时再看.,Fire Prevention
15、Through Operations 生产作业中如何防火,Control Room,Switchgear Room&L/Q 控制房,配电房和生活区,GAS燃气,Positive Pressure,正压,Keep the Doors Closed to Maintain Positive Pressure!随手关门,保持室内正压!,Fire Prevention Through Operations 生产作业中如何防火,Battery Room 电池房,UPS,OXYGEN,电池释放的氢气,Battery Room 电池房,Oxygen is highly explosive,maintain
16、well ventilation 氢气极易爆炸,确保电池房良好通风,Fire Prevention Through Operations 生产作业中如何防火,Oil Soaked Insulation 被油浸泡过的隔热层 Auto-ignition can occur if the pipe/vessel is over 200C and the insulation is oil-soaked.Replace oilsoaked insulation,apply water when conduct this work.温度超过200 C的管线/容器会使沾了油的隔热层发生自燃.应及时更换沾了
17、油的隔热层.更换时应洒水防火.,Fire Prevention Through Operations 生产作业中如何防火,Heating Coils 加热丝 Submerged to Prevent Ignition,为防点火,加热丝不得露出液面,Fire Prevention Through Maintenance 维修作业中如何防火,Portable Tools 手动工具 Hot work permit required when use at hazardous areas,如在有防爆等级要求的区域使用须申请动火作业许可证,Fire Prevention Through Maintena
18、nce 维修作业中如何防火,Fuse 保险丝,DO NOT:Replace when circuit is live Oversize Fuses Shorting out a Fuse,不 要:带电换保险丝用大规格的保险丝将烧坏的保险丝裁 短使用,Fire Prevention Through Maintenance 维修作业中如何防火,Repair to Fire Protection/Fire Fighting Equipment 消防设备的修理-When repair alarm systems,alternative back up protection shall be provi
19、ded.在修理报警系统期间要派人监测.-Without the Supervisors approval,fire water system shall not be taken out of service.没有监督批准,不得 停掉消防水系统.,Fire Prevention Through Maintenance 维修作业中如何防火,Repair to Fire Protection/Fire Fighting Equipment 消防设备的修理-Repair to fire water system shall be tracked daily and given the highest
20、 priority.对消防水系统的修理应当做首要工作并每日 跟踪其进展.-Personnel(Fire Team)shall be notified when fire protection/fire fighting equipment is taken out of service/return service.消防设备暂停使用/恢复使用应通知消防队.,Fire Detection System 火灾探测系统,The following pages are the pictures of fire detectors,see if you know:What they are Where
21、they are installed How they are operatedAsk Instrument Tech.if you have questions.后面几页是一些探测器的照片,您是否知道它们:是什么安装在哪里怎样运用如有疑问请向专业机构咨询,Fire Detection System 火灾探测系统,Fire Detection System 火灾探测系统,Fire Detection System 火灾探测系统,Fire Detection System 火灾探测系统,Fire Detection System 火灾探测系统,Fire Detection System 火灾探测
22、系统,Fire Detection System 火灾探测系统,Maintenance/Calibration 定期维护保养/校验,CACT PM Program,Fire Detection System 火灾探测系统,Maintenance/Calibration 定期维护保养/校验,Each facility is responsible for the calibration of the portable gas detectors on their own facility.See section 11.9.3 of Fire Prevention/Protection SWPP.
23、,Fire Fighting Equipment 灭火设备,How to operate the following fire fighting equipment?如何使用以下灭火设备?1.Portable fire extinguishers(dry powder,CO2,foam)手提式干粉,泡沫,二氧化碳灭火器 2.Fire hoses in L/Q and on deck 生活区内及生产区的消防水带.3.Fire Suppression System(CO2,FM-200)二氧化碳及FM-200 自动灭火系统,Fire Fighting Equipment 灭火设备,How to operate the following fire fighting equipment?如何使用以下灭火设备?4.Wheeled fire extinguisher 轮式干粉灭火器 5.Deluge system 喷淋系统 6.Fire suppression system in kitchen 厨房自动灭火系统,
