《环氧铁红车间底漆的使用方法.doc》由会员分享，可在线阅读，更多相关《环氧铁红车间底漆的使用方法.doc（2页珍藏版）》请在三一办公上搜索。
1、Intended Uses用途经抛丸或喷砂后的钢材作保养底漆，保养期可达3-6个月，也可用钢结构贮藏底漆使用，是一种常温固化的车间底漆，干燥快，物理机械性能优良，能和各类底漆配套，由于不含金属锌等物质，故能减少焊接产生的气体危害Suited for steel shot or grit blasted shop primer with 3-6 months of maintenance period and for steel structure tank as primer as well. Curing at ambient temperature. Quick dry, excellen
2、t physical and mechanical properties. It is able to match with all the primer and may reduce harm of gas risen from electro-weding owing to no zinc etc in them ProductInformation产品简介双组分,铁红色Tw opackages, Iron redApplication details产品数据Volume Solids 固体份25%Dry Flm Thickness干膜厚度25 microns equivalent to
3、100 microns of wet film25微米相当于100微米湿膜厚Theoretical Coverage 理论涂布率8.7m2 /Kg 8.7平方米/公斤Practical Coverage 实际涂布率Allow appropriate loss 允许适量损耗Storage and Handling施工详述Mix Radio 混合比A : B=15:6.4(by weight) 甲:乙=15:6.4Method of Application 施工方法 Airless Spray 无空气喷涂 Recommended 推荐采用 Brush or Roller 涂刷或辊涂 Recomme
4、nded 推荐采用 Conwentional Spray 传统喷涂 Not Recommended 不推荐采用Thinner 稀释剂 SC006 Maximum thining:5% 最大稀释量：5% SC006Cleaner 油漆设备清洗剂 SCOO6Pot Life 使用期 2 5:24h 2 5约24小时Storage 贮存期 One year 一年Drying time 干燥时间SubstrateTemperature底材温度Touch Dry表干(min）Hard Dry硬干(h）Over coating Interval覆涂间隔Min最短Max最长2540.516 hours 小时
5、3months 3个月 环氧铁红车间底漆的使用方法 StorageandHandling贮存与管理Storage 贮存 Store in cool and dry conditions 贮存于阴凉干燥处 Pack size 包装规格 A;15Kg in 20 liter container 甲:15公斤装于20公升容器中 B:6.4Kg in 10 liter container 乙:6.4公斤装10公升容器中Flash Point 闪点 5 Specific Gravity 比重 Approx1.15Kg/L 大约1.15公斤/公升Specification and Surface prep
6、aration技术要求及表面处 理steel surface to be painted should be blaseed to Swedish Standard Sa2.5 or rust-removed manually or with power tool to St3.钢材表面：喷砂处理至瑞典标准 Sa2.5 级或动力工具除锈至 St3级Limitations 限制 Recommend coat: Spary one coat with high-pressure airless spray for the purpose of reaching 20-25 microns of d
7、ry film thickness.Subsequent coat: Epoxy resin paint, coal-tar epoxy paint, chlorinated rubber paint, alkyd resin paint. Phenolic resin paint, chlorosulphonated polythylene anticorrosive paint and rlighly chloronated polyeerylene anticorrosive paint etc.建议涂装道数：高压无空气喷涂一道，干膜厚度达20-25微米后道配套涂料：环氧树脂涂料、环氧沥
8、青涂料、氯化橡胶涂料、醇酸树脂涂料、酚醛树脂涂料、氯磺化聚乙烯防腐涂料、高氯化聚乙烯防腐涂料。 Safety Precautions 安全措施This product should be used in painting area by perfessional operators. When painting , please refer to Product Data Sheet and MSDS. Consult our company if consumers could not completely understand the precautions for safety and
9、health when applying this product.This product is a kind of solvent-based paint .Inorder to avoid danger or accident, minimal safety precautions,as follow , should be down .The paint contains volatile solvent and is flammable . So must keep away from sparks and open flames.No smoking at applacation
10、site ,Effective precautions (such as using explosion-proof electrical equipments. No static electricity accumulation or metal collision etc) also should be done so as to avoid producting sparks .Flash point of paint , mentioned above on product Data sheet, is the lowest temperature at which mixture
11、of the volatile materails of paint can ignite or explode with air. Enough ventilation is necessary at application site. In order to remove any danger of explosion, must keep the ratio of gas to air is less than 10%, the minimum explosive limit in general, Therefore, 200m3 of ventilation quantuty per
12、 1Kg solvent (according to the solvent ) is necessary.Product skin and eyes, and avoid touching with paints (Recommend to wear working clothes, gloves,eye protection, face masks barrier cream and so on ). Kif paint gets in touch with skin , wass fully with large amount of fresh water and soap or app
13、ropriate commercial cleaner. In case of eyes being contaminated, rinse with fresh water for 10min at least and give medical treatment immediately. Recommend face guard with ventilation pipe for the sake of no absorption of paint fog and harmful solvent gas, especially in bad ventilation.Handle empty
14、 containers with care and do not bring about environmental contamination.NOTICE: If consumers have not taken effective safety precautions(Refer to the specfications), our company will NOTbe responsible for any accident. 本产品由专业人缘在工业场所使用,使用时请参照本说明书及健康安全手册,如客户在使用本产品前,未能仔细了解有关产品的健康安全知识,请与本公司联系.该涂料为溶剂型涂料
15、,为避免事故或危险发生,应采取最低限度的安全措施如下:此涂料为易燃物,并含有挥发性易燃溶剂,故必须远离火星和明火,严禁在作业场所吸烟,并采取有效措施,防止火星产生(如采用防爆电器设备,杜绝静电积累,避免金属撞击等)本产品说明书中所列涂料及溶剂的闪点是引起燃烧的最低温度. 施工场所应尽量进行通风良好,为消除使用过程中的爆炸隐患,应保证足够的通风量以维持气体/空气比例不超过最低爆炸极限的10%,通常每千克溶剂需要200立方米通风量,(与溶剂种类相关)就能维持最低爆炸极限10%的工作环境.采取有效措施以防止皮肤和眼睛与涂料接触(如使用工作服,手套,护目镜,面罩及涂防护油等)如产品不慎接触到皮肤,应用温水及肥皂或适当的工业清洁剂彻底清洗,如眼睛受到污染,用清水冲洗至少10分钟,并立即就医.建议佩戴通风面罩以避免吸入漆雾和有害溶剂气体,尤其在通风不良环境下施工时,细心处理旧漆桶以免污染环境. 责任声明: 对于未按本公司要求采取有效安全措施儿引起的安全事故,本公司不负任何责任.来源
