《SSX弧齿锥齿轮行星齿轮减速器系列.doc》由会员分享，可在线阅读，更多相关《SSX弧齿锥齿轮行星齿轮减速器系列.doc（6页珍藏版）》请在三一办公上搜索。
1、 系列弧齿锥齿轮-行星齿轮减速器是专门为带式输送机研制开发的新一代传动装置，用于替换原有展开式定轴传动的标准减速器。系列减速器不仅在设计方法、专利技术的应用和制造工艺上取得了许多突破和成功尝试，而且分别通过了在上海的“国家采煤机械质量监督检测中心”和西安“国家冶金重型机械质量监督检验中心”进行的试验室满载一千小时连续台架试验考核。该系列产品已通过煤炭科学研究总院的技术鉴定，并获得广泛应用，九五年获煤炭部科技进步三等奖。系列减速器同时还已广泛地用于矿山、冶金、运输、码头、建材、化工、纺织等行业。 1 显著特点 a、.结构紧凑，体积小，重量轻，承载能力大，单位重量输出扭矩达到3.8Tm/T; b、
2、传动效率高，二级传动满载效率实测96.54%,三级传动满载效率实测95.77%，运转平稳，噪音低； c、减速器齿轮均为硬齿面，齿轮、轴承等啮合部位均强制润滑，故整机热功率大，使用寿命长； d、系列减速器可同时实现带式输送机的左右侧安装，并且可同时安装制动器和逆止器，因此特别适合煤矿井下各类固定或可伸缩带式输送机使用。 2 适用条件 输入转速不超过 1500 r/min； 工作环境温度为 -30+45； 可正反向旋转。 3 标记示例 S S X 2 5 0 - 4 0 A ( B ) G 改进型 结构形式：A: 悬挂式 B: 落地式 减速比 输入功率(Kw) 系列型号 4 选用说明 SSX系列减
3、速器自带润滑油泵和外接高效冷却器实行强制润滑和冷却，故减速器的热功率即为名义输入功率。冷却方式为水冷或油冷。水冷时必须有冷却水源并使水通过高效外接冷却器实行冷却，油冷时由辅助油箱实行冷却，而辅助油箱通过软管及自带润滑油泵与减速器内的油实行循环。辅助油箱不占用任何有效巷道空间。 SSX系列减速器的选用只要根据工作机构的输入功率或驱动扭矩，减速比及安装形式就可直接选择相应的型号，其中已考虑带式输送机的使用功况。表1 减速器系列动力参数输入转速1500 r/min 输入功率（Kw）减速比75132200250315355375400输出扭矩（N.M）1677001380020700258003260
4、03670038800414001887001530023300291003670041300437004660020970017000258003230040700445900485005170025121002130032300404005090057400606006470031.5152002690040700509006420072400784008150035.5172003030045900574007240081500861009190040194003410051700647008150091900971001035004521800384005820072800917001
5、034001092001165005023300427006470080900101900114900121400129500图1 SSX悬挂式（A型）外形及安装尺寸图6 SSX外形及装配尺输入功率（Kw）：200250 输入转速（r/min）：1484总数比2830.535.240输出转速(r/min)5347.141.838.1输出扭矩(KN.m)4550.757.164.4注：1、输出轴可按客户要求修改成涨套或花键联接； 2、订货时请注明“N”，是否有逆止器；输出轴型式。图7 SSX外形及装配尺寸输入功率（Kw）：200250 输入转速（r/min）：1484总数比2830.535.24
6、0输出转速(r/min)5347.141.838.1输出扭矩(KN.m)4550.757.164.4注： 1、输出轴可按客户要求修改成涨套或花键联接； 2、订货时请注明“S”，是否有逆止器；输出轴型式。 图1 SSX悬挂式（A型）外形及安装尺寸型号LL1L2L3L4L5L6L7dd1d2E1F1E2F2ABCDGA1G1M重量kgSSX75-16A60714540820014537217010140h665k685k6185822766105407006205653903501626950SSX75-18A60714540820014537217010140h665k685k618582276
7、6105407006205653903501626950SSX75-20A60714540820014537217010140h665k685k6185822766105407006205653903501626950SSX75-24A60714540820014537217010140h665k685k6185822766105407006205653903501626950SSX75-28A70014562020014550020010155h665k685k61858227670054070062064039035016261000SSX75-31A7001456202001455002
8、0010155h665k685k61858227670054070062064039035016261000SSX75-35A70014562020014550020010155h665k685k61858227670054070062064039035016261000SSX75-40A70014562020014550020010155h665k685k61858227670054070062064039035016261000SSX75-45A70014562020014550020010155h665k685k61858227670054070062064039035016261000
9、SSX132-16A60714540820014537217010155h665k685k61858227670054070062064039035016261150SSX132-18A60714540820014537217010155h665k685k61858227670054070062064039035016261150SSX132-20A60714540820014537217010155h665k685k61858227670054070062064039035016261150SSX132-24A60714540820014537217010155h665k685k618582
10、27670054070062064039035016261150SSX132-28A75014562020014550020010180h665k685k61858287685054070062077036033516261200SSX132-31A75014562020014550020010180h665k685k61858287685054070062077036033516261200SSX132-35A75014562020014550020010200h665k685k61858287685054070062077036033516261300SSX132-40A750145620
11、20014550020010200h665k685k61858287685054070062077036033516261300SSX132-45A75014562020014550020010200h665k685k61858287685054070062077036033516261300SSX200-16A62012552023018041510180h695k6258680054070062075036033516261530SSX200-18A62012552023018041510180h695k6258680054070062075036033516261530SSX200-20
12、A65012352023018041510180h695k6258680054070062075036033516261530SSX200-24A65012352023018041510180h695k6258680054070062075036033516261530SSX200-28A74013065023018041510200h695k6258692054070062088047243416261720SSX200-31A74013065023018041510200h695k6258692054070062088047243416261720SSX200-35A74013065023
13、018041510200h695k6258692054070062088047243416261720SSX200-40A76015065023018041510210h695k62586103054070062098047243416261840SSX200-45A76015065023018041510210h695k62586103054070062098047243416261840SSX250-16A62012552023018041510180h695k6258680054070062075036033516261650SSX250-18A620125520230180415101
14、80h695k6258680054070062075036033516261650SSX250-20A65012552023018041510180h695k6258680054070062075036033516261650SSX250-24A75013065023018041510200h695k6258692054070062088047243416261860SSX250-28A74013065023018041510200h695k6258692054070062088047243416261860SSX250-31A74013065023018041510200h695k62586
15、92054070062088047243416261860SSX250-35A76015065023018041510210h695k625861080540700620102047243416262100SSX250-40A76015065023018041510210h695k625861080540700620102047243416262100SSX250-45A76015065023018041510210h695k625861080540700620102047243416262100SSX400-18A85015061024520073420015210h6120k6160k63
16、210940147100064088072095047239616322100型号LL1L2L3L4L5L6L7dd1d2E1F1E2F2ABCDGA1G1M重量kgSSX75-16A60714540820014537217010140h665k685k6185822766105407006205653903501626950SSX75-18A60714540820014537217010140h665k685k6185822766105407006205653903501626950SSX75-20A60714540820014537217010140h665k685k61858227661
17、05407006205653903501626950SSX75-24A60714540820014537217010140h665k685k6185822766105407006205653903501626950SSX75-28A70014562020014550020010155h665k685k61858227670054070062064039035016261000SSX75-31A70014562020014550020010155h665k685k61858227670054070062064039035016261000SSX75-35A70014562020014550020
18、010155h665k685k61858227670054070062064039035016261000SSX75-40A70014562020014550020010155h665k685k61858227670054070062064039035016261000SSX75-45A70014562020014550020010155h665k685k61858227670054070062064039035016261000SSX132-16A60714540820014537217010155h665k685k61858227670054070062064039035016261150
19、SSX132-18A60714540820014537217010155h665k685k61858227670054070062064039035016261150SSX132-20A60714540820014537217010155h665k685k61858227670054070062064039035016261150SSX132-24A60714540820014537217010155h665k685k61858227670054070062064039035016261150SSX132-28A75014562020014550020010180h665k685k618582
20、87685054070062077036033516261200SSX132-31A75014562020014550020010180h665k685k61858287685054070062077036033516261200SSX132-35A75014562020014550020010200h665k685k61858287685054070062077036033516261300SSX132-40A75014562020014550020010200h665k685k61858287685054070062077036033516261300SSX132-45A750145620
21、20014550020010200h665k685k61858287685054070062077036033516261300SSX200-16A62012552023018041510180h695k6258680054070062075036033516261530SSX200-18A62012552023018041510180h695k6258680054070062075036033516261530SSX200-20A65012352023018041510180h695k6258680054070062075036033516261530SSX200-24A6501235202
22、3018041510180h695k6258680054070062075036033516261530SSX200-28A74013065023018041510200h695k6258692054070062088047243416261720SSX200-31A74013065023018041510200h695k6258692054070062088047243416261720SSX200-35A74013065023018041510200h695k6258692054070062088047243416261720SSX200-40A7601506502301804151021
23、0h695k62586103054070062098047243416261840SSX200-45A76015065023018041510210h695k62586103054070062098047243416261840SSX250-16A62012552023018041510180h695k6258680054070062075036033516261650SSX250-18A62012552023018041510180h695k6258680054070062075036033516261650SSX250-20A65012552023018041510180h695k6258680054070062075036033516261650SSX250-24A75013065023018041510200h695k6
