《PCB MSDS .doc》由会员分享，可在线阅读，更多相关《PCB MSDS .doc（9页珍藏版）》请在三一办公上搜索。
1、中山市精华电子原料有限公司Material Safety Data Sheet物质安全资料表一、物品与厂商资料表Material name and supplier information物品名称NameGH-8001BKD同义名称DescriptionFluid sensitive solder mask ink液态感光阻焊油墨制造商或供货商名称Supplier name中山市精华电子原料有限公司制造商或供货商地址Supplier address中山市三角镇高平工业区紧急联络电话Phone number（0760）88360191传真电话Fax（0760）88701239二、分辨识资料Dis
2、tinguish information物料主要成分明细Chief ingredient of material：主要成分名称CAS.NOpercentage主要成分百分含量Hazard material classify危险物质分类亚克力树脂acrylic resin44.56丙烯酸单体acrylic acid28961-43-58.06甲阶酚醛环氧树脂novolac epoxy resin5.36高沸点溶剂 solvent with high boiling point64742-94-510.06硫酸钡barium20.06光引发剂photo-initiator71868-10-56.2
3、6助剂additives6.06三、危害辨识资料最重要的危害效应The most important toxic effectInhibitory Effects on the central Nervous System, may into lung while swallow or vomit, may cause loss of consciousness会抑制中枢神经系统，吞食或呕吐时可能倒吸肺部，高浓度暴露可能道致意识丧失。健康危害效应health hazardThe steam will be decomposed by react with free radical of hyd
4、rogen in the air蒸气释放至大气中会与氢气自由基作用而快速分解掉。环境影响environmental pollutionThe steam is lighter than air and easy to spread其蒸气比空气轻，易传播至远处。物理性及化学性危害Physical and Chemical hazardThe steam is lighter than air and easy to spread其蒸气比空气轻，易传播至远处。特殊危害Other hazards主要症状main symptomsHeadache, vomit, faint, tire, in app
5、etence, dry skin, swelling, cornea heat, irregular heartbeats, difficulty breathing, dizzy 头痛、呕吐、晕眩、疲劳、食欲不振、皮肤干裂且灼热、红肿、角膜灼热、心率不整、呼吸困难、头晕眼花。物品危害分类hazard class3 (poisonous substance) 3（毒性物质）四、Emergency measures紧急措施First aid of different way不同暴露途径之急救方法：Inhalation:1.remove the pollution source or supply
6、 fresh air to the patient2.Go to hospital ASAP吸入：1、移除污染源或将患者移至新鲜空气处。2、立即就医。Skin touched:1 Wash the polluted place 5minutes by water and soap皮肤接触：1、以水及肥皂冲洗受污染部位5分钟，或直到污染物除去。Eye touched:1.Wipe off or sponge up the left chemicals ASAP 2.Shove out eyelid, wash 15minute with warm water眼睛接触：1、尽快插掉或吸掉多余的化学
7、品。 2、立即将眼皮撑开，用流动的温水缓和冲洗15分钟，或直到污染物除去。Eaten:1.If the patient has loss his consciousness, any food is forbidden to feed 2.Dilute the chemical composition in stomach with 240300ml water 3.If patient vomit suddenly, pitch the patient to decrease the possibility of inhalation, patient should keep on garg
8、le 4.Go to hospital immediately食入：1、患者即将丧失意识或已无意识时，不可喂食任何东西。2、给患者喝下240300毫升的水以冲释胃中的化合物。3、若患者有瞬息万变发性的呕吐时，应使患者身体向前倾以减低吸入的危险，并让其漱口以及反复给水。4、立即就医。The most important symptom and hazard effect : Steam can stimulate eyes, mucosa and skin, high concentration may cause anesthesia最重要的症状及危害效应：蒸气会刺激眼睛、粘膜和皮肤：高浓度会
9、引麻醉The protection of paramedic: Give first aid in safety area with C class protection armor对急救人员之防护：应空着C级防护装备在安全区实施急救。Notice to doctor对医师之提示：五、Quench fire method减火措施Available fire extinguisher: dry powder, High Efficient Environment Protection, Water适应减火剂：化学干粉、高效环保减火器、水。Other hazard while quench fir
10、e: Stop to leak before quench fire, or the poisonous gas in the air may harm body减火时可能遭遇之特殊危害：减火前先停止泄露，否则空气中有毒气体过高容易危害人体。Special protection for fire man: Air respirator, fire-fighting clothes, protection gloves消防人员之特殊防护设备：空气呼吸器、消防衣、防护手套。六、Leakage treatment methods泄露处理方法Matters needing attention of p
11、eople个人应注意事项：1. Limit to outward-inward until clean finished2. Clean by trained people3. Wear proper protection armor1、 限制人员出入，直至外益区完全清理干净为止。2、 由受过训练之人员负责清理干净。3、 穿戴适当的个人防护装备。Matters needing attention of environment: Isolate the fire source, keep the air fresh on leakage area and notice to occupation
12、al safety and environment department of government环境注意事项：将火源存放区隔离，并对泄露区通风换气，立即通知政府职业安全卫生及环保相关单位。Cleaning method清理方法：1. Dont touch leakage2. Avoid leakage flow into cloacae or narrow space3. Try to decrease leakage if possible4. If a little leakage, use mud, sand and similar nonflammable material to
13、cover5. If very much leakage, contact fire fighting, emergency department or supplier1、 不要碰触外泄物。2、 避免处泄处进入下水道或狭的空间内。3、 在安全许可的情形下，设法组织或减少益漏。4、 少量泄露时，用不会和外泄物反应的泥土、沙和类似稳定且不可燃的物质者处泄物。5、 大量泄漏时，联络消防、紧急处理单位以及供货商寻求协助。七、prevent for leakage暴露预防措施Use处置：1. Avoid extraneous force to make leakage while using2. Us
14、e with minimal in drafty place3. Emergency device is needed1、 使用时注意勿有外力道致倾斜泄漏。2、 在通风良好的指定场所最小量使用。3、 须备有处理泄漏的紧急应变装置。Storage储存：Store in shady and cool, clean, drafty and direct sunlight, far away from fire source and incompatible place储存于阴凉、干净、通风良好以及阳光直射的地方，远离火源及不兼容处。八、Physical and Chemical characteri
15、stic 物理及化学性质Process control工程控制：1. Separate the evacuation system with ventilation system which earthing and without sparks2. Exhaust gas exhaust to outdoor and appropriate measures are needed3. Use partial exhaust and close process while handling4. Supply enough fresh air to renew the air in system
16、1、 使用时，以不产生火花及接地的通风系统并与一般排气系统分开。2、 厂气直接排到户外并对不幸保护采取适当措施。3、 在量操作时，使用局部排气和密闭制程。4、 提供充分新鲜空气以补充系统排除之空气。Parameter控制参数Average allowance consistence of 8 hours八小时时量平均允许浓度Average allowance consistence of short time短时间时量平均容许浓度Maximum allowance consistence最高容许浓度Biological index生物指标25PPM（CEAC） 700PPM以下（DEAC） 5
17、0PPM（DEAC）Protection device个人防护设备：Breathe protection: Organic filtering Respirator if less than 700ppm Regular respirator if unknown consistenceHand protection: Seepage control gloves, polyethylene ethanol, VITON、4H、BARRICADEEye protection: Face Shield, Safety GlassesSkin and body protection: Protec
18、tive clothing, A piece working rig, work shoes呼吸防护：700PPM以下含有机滤毒之呼吸防护具。 未知浓度：正式自揣式呼吸防护具。手部防护：防渗手套、优质聚乙稀醇、VITON、4H、BARRICADE为佳。眼睛防护：防护面罩、化学安全护目镜。皮肤及身体防护：上述塑料防护衣、连身工作服、工作靴。Sanitary measures:1. take off polluted clothing after working, clean it before reuse or discard it, and should notice the hazard o
19、f polluted clothing2. Smoking and eating is forbidden on working site3. Wash hand drastically after get rid of it4. Keep working site clean卫生措施：1、 工作后尽快速脱掉污染之衣物，洗净后才可再穿戴或丢弃，且须告知洗衣人员污染物之危害。2、 工作场所严禁抽烟或饮食。3、 处理此物后彻度洗手。4、 维持作业场所清洁。九、Physical and chemical characteristic物理及化学性质Material condition物质状态：Liqu
20、id液态Shape形状：Sticky fluid粘稠流体Color颜色：Black黑色Smell气味：aroma含久香味PH value值：67Flash temperature闪火点： 130； Test method测试方法：Open the can开杯Decomposition temperation分解温度：300Explosion limit爆炸界限spontaneous combustion temp.:自燃温度：Cannot spontaneous combustion不自燃Steam density蒸气密度：0.9g/cm3Steam pressure蒸气压:04mmHg/25
21、Insoluble in water不溶于水Density密度:1.2(water水=1)Viscocity粘度(25)：260300ps十、Stability and Reactivity安定性及反应性Stability安定性：stable under normal condition正常状态下安定。Possible hazard react: 特殊善下可能之危害反应：Over gasification material过气化物、Strong reducing agent强还原剂、剧烈反应、增加反就剧烈物质。Far away from: leakage, fire and other fir
22、e source应避免之善：泄露、火灾和其它火源。To avoid: 1.Strong gasification material 2. Strong reducing agent 3.Halogen and acid compound 4. Reacts violently with water应避免之物质：1强气化剂;2.强还原剂;3.酸卤化合物;4.与水反就剧烈物质，Hazard material after decomposed: Heat decompose generate CO、CO2、NO、CH2O3危害分解物：热分解产生CO、CO2、NO、CH2O3。十一、Poisonous
23、 information毒性资料Urgent toxicity: Liquid, steam will stimulate eye, mucosa and skin急毒性：液体、蒸汽会刺激眼睛物、粘膜和皮肤。Inhalation:1. Inhale 200ppm density will stimulate throat 2.Inhale 700ppm density will vomit 3.Inhale high density(1000ppm) will cause uncoordinated, loss consciousness, respiratory failure and de
24、ath 4.Inhale deeply will cause liver and kidney damage吸入1.短暂的暴露于200PPM浓度会刺激和喉咙.2.暴露于700PPM浓度会引起恶心和呕吐.3.暴露于高浓度(大约1000PPM)会引起动作不直协调、失去意识、呼吸衰竭甚至死亡。4.暴露于高深度会引起肝臓和肾臓损害.Skin:1.Touch will cause erythema xerosis and degrease, long time touch will cause dermatitis 2.Steam will stimulate skin皮肤:1.接触会引起红斑干燥和脱脂
25、，长期接触引起皮肤炎。2.蒸汽会刺激皮肤。Eye:1.Steam will stimulate eyes 2.Fluid will stimulate eyes seriously眼睛1.蒸汽会造成刺激。2.其液体对眼睛具有严重刺激。Eaten:1.Stimulate throat esophagus and stomach 2.Symptom of eaten a lot is similar with inhalation 3.May cause lung damage while inhale into lung食入1.刺激咽食道和胃。2.大量食入之症状与吸入症状类似。3.若吸入肺部会引
26、起致命的肺部伤害。Partial effect局部效应：500mm/24H (rabbit skin) cause tightly stimulation 57mm/24H (rabbit skin) cause middle stimulation500mm/24H(兔子皮肤)造成轻微刺激。 57mm/24H（兔子皮肤）造成中度刺激。Sensibility致敏感性：Chronic toxicity:1.Expose for a long time may cause dermatitis2. Liver and kidney damage慢性毒或长期毒生：1.反复或长期暴露可能引起皮肤炎(干
27、燥、龟裂)。 2肝臓和肾臓损害。Other effect特殊反应： 十二、Environment information生态资料May influence可能之环境影响/环境流布1. Release to atmosphere will react with free radical of hydrogen in the air2. Release to water will be discharged by steam effect3. Release to soil will volatilized and filter into soil1 释放至大气中会与氢气自由反应而快速分多解掉。2
28、 释放至水中最主要由蒸汽作用排除掉。3 释放至土壤中会挥发及渗入地下。十三、Exhaust gas treatment method废气处置方法Exhaust gas treatment method废气处置方法：1. Refer related laws2. Get rid of the exhaust gas under storage condition3.1 参考相关法规处理。2 依照仓储条件待处理的废弃物。3 可采用特定的变化呀衍生掩埋法处理。十四、Shipping information运送资料国际运送规定：联合国编号：Domestic transportation rule: 国
29、内运送规定：1.Road traffic safety rule:#842.Shipping hazard goods load rules3. Hazard goods load rules detail1.道路交通安全规则第84条。2.船舶危险品装载规则。3.台湾铁路局危险品装卸运输实施细则。Special shipping method and attention特殊运送方法及注意事项：十五.Legislation documents法规资料General rules:Labor safety health implement ruleOrganic solvent toxicosis
30、prevent ruleRoad traffic safety ruleHazard goods common ruleLabor operation environment hazard material allowance density standardStorage and discard method standard of hazard good通用法规:劳工安全卫生设施规则。有机溶剂中毒预防规则。道路交通安全规则。危险及有害物通识规则。劳工作业环境空气中有害物质容许浓度标准。事业诚心弃物储存处理方法设施标准。十六、Other documents其它资料参考文献1. CHEMINFO数据库，CCINFO光盘，98-22. HAZARDTEXT数据库，TOMES PLUS光盘，Vol.41，19993. RTECS数据库，TOMES PLUS光盘，Vol.41，19994. HSDB数据库，TOMES PLUS光盘，Vol.41，19995.危害化学物质中文数据库，环保署制表者单位名称：中山市精华电子原料有限公司住址：中山市三角镇高平工业区 电话：0760-88360191制 表 人职称：技术主办姓名（签章）：黎红有制表日期2008-7-31上述数据由中山市精华电子原料有限公司提供，对上述数据已力求正确，但错误恐仍难免，各项数据与数据仅供参考，使用者请依应用需求。
