《消防、救生设备登记检查养护记录簿.doc》由会员分享，可在线阅读，更多相关《消防、救生设备登记检查养护记录簿.doc（23页珍藏版）》请在三一办公上搜索。
1、安杰船务有限公司ANGEL SHIPPING(HONGKONG) CO.,LIMITED地址：上海市大连路950号海上海新城8楼1606室Address:Room 1606, 8Bldg Shanghai Xin Cheng, 950 DALIAN Rd, Shanghai 200092, P.R.China 消防、救生设备登记检查养护记录簿Fire-Fighting and Lifesaving EquipmentInspection and Maintenance Record船舶Ships Name 自 年 月至 年 月From y m To y m记 录 说 明1、 为了满足国际海事组
2、织、主管机关和各船级社的规定和要求，确保消防、救生设备的完整，进一步完善养护记录，制订了本记录簿。2、 此记录簿由三副记录和填写，填写时必须仔细、认真、载入正确、字迹清楚、整洁。并按SOLAS要求，将“救生设备月度检查报告”简要载入航海日志中。3、 消防、救生设备的配备数量、检查周期等都根据国际海事组织（IMO）通过的国际海上人命安全公约（1974年SOLAS）和历届修正案规定和要求。4、 本记录簿中部分设备不属三副主管，请相关主管人员协助完成，由三副记录，共同签字。5、 三副必须按规定的周期进行消防、救生设备的检查和养护，如发现缺陷应及时记录，尽量自行整改，或告大副、船长，由船上整改。必要时
3、报公司有关部门帮助整改。6、 三副必须按规定三个月将此记录簿送交大副、半年送交船长签阅，大副、船长在查阅后，发现问题应及时给三副以指导。7、 主管部门来船检查时三副应将此记录簿交主管人员审阅。8、 记录簿用完后必须在船保留3年以上。目 录Index1.消防设备清单The Inventory of Fire-Fighting Equipments 2.救生设备清单The Inventory of Lifesaving Equipments3.备品登记表Spare Parts Records4.船长、大副查阅记录Master, C/O Check Record5.消防救生设备每周检查表Life s
4、aving equipment and Fire fighting equipment weekly inspection record6.消防救生设备每月检查表Life saving equipment and Fire fighting equipment monthly inspection record6.1 救生艇每月检查明细表Lifeboat monthly inspection record6.2 放艇装置每月检查明细表Launch arrangement for lifeboat monthly inspection record6.3 救生筏每月检查明细表Life-raft
5、Monthly inspection record6.4 救生衣每月检查明细表Life jacket monthly inspection record6.5 救生服/抗曝露服每月检查明细表 Immersion suit and anti-exposure suits monthly inspection record6.6 救生圈每月检查明细表Life-buoy monthly inspection record6.7 EEBD每月检查明细表EEBD monthly inspection record6.8 消防员装备每月检查明细表Firemens outfit monthly inspec
6、tion record6.9 手提式灭火器每月检查明细表Portable extinguisher monthly inspection record6.10 消防箱和皮龙每月检查明细表Hoses & hose boxes monthly inspection record6.11 固定式灭火系统每月检查明细表Fixed fire fighting system monthly inspection record6.12 防火探测系统每月检查表Fire detecting system monthly inspection record6.13 空气压缩机每月检查明细表Air compress
7、or monthly inspection record6.14 抛绳器每月检查明细表Throwing Appliance monthly inspection record6.15 国际通岸接头每月检查明细表 International connection monthly inspection record消 防 设 备 清 单The Inventory of Fire-Fighting Equipments 水灭火系统water fire-fighting systems系统设备名称Items型号Type数量Amount自动报警系统Auto-alert system探火报警器型号Type
8、 of fire alarm equipmentSalwicoCS4000主消防泵main fire pump125CLLa-8A1其他水泵other pumps150CLZ-7/21探测器类型Type of detector感烟/感温水带HoseF65A/50A4/18数量Amount38/12水枪nozzles50A18生产厂ManufactureNITTAN(UK)LTD消火栓hydrantF65A/50A6/20出厂年月Produced date国际通岸接头International connection通用标准2应急消防水泵Emergency fire pump80CWZ-61固定灭
9、火系统fixed fire-fighting system钢 瓶 Cylinder 容量Capacity数量Amount总量Total Volume被保护处所Protective Location68L302040L瓶头阀Valve on Bottle接口口径Diameter of Connection型式Type140mmWGA泡沫灭火系统the foam system泡沫液柜容量capacity of foam container2.9立方米泡沫液型号Type of foamPROVEX AR3-3生产厂ManufactureSEAPLUS. CO. LTD甲板泡沫炮数量The amoun
10、t of monitor on deck6其他消防工具other equipments名称items规格型号type数 量amount存放位置Location应配legal requirement实有 Actual onboard太平斧 axe大号23船头/船尾撬棒crowbar小号24消防仓库铁钩hook大号22消防仓库沙箱sand container水桶drums塑料22消防仓库救 生 设 备 清 单The Inventory of Lifesaving Equipments救生艇信号lifesaving signal名称items生产厂家manufacture数量amount有效期val
11、idity更换日期Renew date备注Remark红光降落伞rocket parachute flare常州市三井水上救生用品厂42008.112011.112011.10红光火焰hand-fare signal常州市三井水上救生用品厂62008.112011.112011.10橙色烟雾smoke signal常州市三井水上救生用品厂22008.112011.112011.10驾驶台信号lifesaving signal on bridge红光降落伞rocket parachute flare带灯烟雾信号Smoke signal中国江苏海门市华海水上安全设备有限责任公司22012.0320
12、12.02抛绳器Throwing appliance 中国江苏海门市华海水上安全设备有限责任公司12012.032012.02个人救生器材personnel lifesaving equipments救生服Immersion suit无锡兴泰船舶设备有限公司26救生圈Life-buoy无锡兴泰船舶设备有限公司16救生圈灯light on life-buoy无锡兴泰船舶设备有限公司6救生衣灯Light on lifejacket无锡兴泰船舶设备有限公司26救生衣lifejacket无锡兴泰船舶设备有限公司26救生艇有时效物品Good on lifeboats名称items生产日期Produced
13、 date有效期validity数量amount更换日期Renew date备注Remark急救药箱first aids2008.1124个月1201010晕船药片Anti-seasickness medicine2008.093年1202011.08口粮（袋）Food ration2008.093年202011.08淡水（升）Drink water2008.093年203L2011.08 备 品 登 记 表Spare Parts Records名称Items型号Type数量Amount生产日期produced date有效期Validity存放位置Location 备注Remark 空气钢瓶
14、5L9防火仓库EEBDTHDF15-I17安全仓库干粉灭火器MFZ/ABC-617安全仓库泡沫灭火器MSZ-917安全仓库水雾枪头50A3防火仓库防火毯XU-1071防火仓库泡沫桶20L1防火仓库泡沫救生衣JHY55645防火仓库太平斧大号1防火仓库救生圈32-5kg2防火仓库防火绳标准1防火仓库皮龙接头50防火仓库皮龙接头65防火仓库皮龙带506防火仓库救火皮龙带401防火仓库橡皮垫圈尺寸：220防火仓库橡皮垫圈尺寸：1/220防火仓库灭火水带40MM1防火仓库船长、大副查阅记录Master, C/O Check Record日期date大副/船长查阅意见记录The instruction
15、given by C/O or Master签名signature救生消防设备每周检查表(20 年第 周)Life saving equipment and Fire fighting equipment weekly inspection record签 名 Signature 检查项目Items结果 Result救生设备Life saving equipments: 检查日期Date ： 救生艇 1#(兼救助艇)No.1 Lifeboat(Rescue Boat)：目视检查，确保立即可用Visual inspection; To be used immediately救生艇 2#(兼救助艇
16、)No.2 Lifeboat(Rescue Boat)：目视检查，确保立即可用Visual inspection; To be used immediately 救生艇 1#(兼救助艇) 降落设备Launching apparatus of No.1 lifeboat(Rescue Boat)：目视检查，确保立即可用Visual inspection; To be used immediately救生艇 2#(兼救助艇) 降落设备Launching apparatus of No.1 lifeboat(Rescue Boat)：目视检查，确保立即可用Visual inspection; To
17、be used immediately救生艇1#(兼救助艇)发动机正倒车试验总时间不少于3分钟(环境温度许可时)Test the propeller ahead and astern not less than 3 minutes(while the ambient temperature permission)救生艇2#发动机正倒车试验总时间不少于3分钟(环境温度许可时)Test the propeller ahead and astern not less than 3 minutes(while the ambient temperature permission)救生筏Life raf
18、t：目视检查，确保立即可用Visual inspection; To be used immediately其他Others消防设备Fire fighting equipments 检查日期Date ： 主消防泵Main fire pump应急消防泵Emergency fire pump应急消防泵处所The location of emergency fire pump is clear and non-obstruction.通用紧急报警系统General alert system, test and clean the main control panel.所有的公共广播系统For all
19、 the public address, test and clean the main control panel.固定时探火和失火报警系统定式探火和失火报警系统Fixed detecting system防火门，防火闸，逃生路线，天窗 Fire doors, fire dampers, means of escape, skylights, 自动喷淋系统the auto-spraying system其他Others救生消防设备每月检查表Life saving equipment and Fire fighting equipment monthly inspection record(2
20、0 年第 月)签 名 Signature 救生艇每月检查明细表Lifeboat monthly inspection record1)艇体部分Hull Part 检查日期Date项目Item描述Describe记录Inspection column注释Remark内部Inner side检查刮痕和破损Check of scratches and Damage外部Outer side检查刮痕和破损Check of scratches and Damage艇体玻璃缸部分FRP part检查刮痕和破损Check of scratches and Damage金属构件Metal part锈蚀Rusti
21、ng脱钩装置Hook Release Device检查释放能力和锈蚀情况Check of release capabilities and rusting系索脱开装置Painter Release Device检查释放能力和锈蚀情况Check of release capabilities and rusting入艇开口Embarkation Hatch andOpening检查密封状况和润滑,锁闭装置的情况Checking of sealing condition and lubrication of hinges and clip观察窗Window检查是否有裂变,确认关闭状况和观察玻璃情况
22、Checking of cracks, Confirmation of opening/ closing and mop glass舵设备Steering Device检查舵系统的操作工具和应急舵柄的连接Checking of operation by steering kit and connection of emergency tiller艉轴tern tube检查外包部件Checking of packing gland舵叶Rudder检查舵叶,舵柄和应急舵柄Checking of rudder, tiller and emergency tiller通风机Ventilator确认开关
23、Confirmation of opening/ closing2)艇机部分Engine Part 检查日期Date项目Item检查点Check point检查结果Inspection result注释Remark艇机Engine检查海水密封情况Checking of tightening sea bolt主机滑油Engine lub. Oil 离合器滑油Crutch lub. Oil检查滑油在油柜内和离合器箱内的油量Checking of lubricating oil quantity in oil pan and clutch case滑油过滤器Lub. Filter清除滑油过滤器内的残
24、渣Discharge dust collected in filter燃油柜Fuel oil tank检查安装的油柜状况和柜内的油量Checking of installed condition and oil quantity in fuel oil tank管线Pipe line检查管线之间的连接没有渗漏Make sure the joints does not leak淡水柜Fresh water tank检查冷却水水柜水量Checking of cooling fresh water quantity淡水管线和泵浦Fresh water pump and pipe line确认管线没有
25、渗漏Make sure the pipe line does not leak3）救生艇（救助艇）设备清单Life-Boat ( Or Rescue Boat ) Equipments检查日期Date编号No项目Item数量Qty检查结果Inspection result说明Remark1桨Oar2桨杈Clutch3艇钩Boat hook4水斗Bailer5桶Bucket6艇用斧头Hatchet7罗盘Compass8海锚Sea anchor9系索Painter10食品Food ration11饮用水和水箱Drinking water and tank12漏斗Dipper13Drinking v
26、essel14急救箱First-aid outfit15抗晕浪药和急救包Anti-seasickness medicine and bag16保温服Thermal protective aid17V型刀Jack-knife18开罐头刀Tin-opener19带浮力圈的救生索Buoyant rescue quoits20口哨Whistle21渔具Fishing tackle22操作手册Actions instruction Manual23救生手册Survival manual24规定的救生信号Life-saving signal Prescribed25降落伞火焰信号Parachute sig
27、nal26闪光火焰信号Flare signal27漂浮的烟雾信号Buoyant smoke signal28艇机修理工具Tools for engine29手泵Hand pump30防水电筒Water-proof electric torch31反光镜Daylight signaling mirror32雷达反射器Radar reflector33手提式灭火器 Portable fire-extinguishing equipments34雨水收集器Rainwater storage device35探照灯Search light36应急舵Emergency steering tiller37
28、拖带缆Tug line38其他Others4). 工具Tools 检查日期Date编号No项目Item标准Standard数量Quantity检查结果Inspection result注释Remark1工具箱Tool boxPlastics12扳手Spanner10x1313扳手Spanner12x1414扳手Spanner17x1915扳手Spanner22x2416可变螺母Screw driverChange type17喷射泵Evacuation pump1 set5). 自给空气系统Air Self-Supply System检查日期Date项目Item检查点Check point检查
29、结果Inspection result注释Remark压缩空气Compressed 空气箱Gas Container检查是否从空气阀有渗漏,检查安装状态Checking of air leakage from source valve , Checking of installed condition连接管线Connecting pipe检查管线的布局Checking of pipe laying调节阀Adjuster检查调节阀和压力表的的状况Checking of adjuster and crack of pressure gauge glass6). 撒水系统WATER SPRAY SY
30、STEM 检查日期Date项目Item检查点Check point检查结果Inspection Result注释Remark整个系统Whole system检查紧固螺丝和螺帽Checking of tightening set bolts and nuts etc泵浦Pump检查安装的状态Checking of installed condition离合器Clutch检查离合器的开关位置Checking of clutch ON or OFFV型滑车和皮带V-pulley and belt检查V型皮带Checking of V-belt管系布局和喷嘴Pipe laying and nozzle
31、检查是否锈蚀Checking of rusting检查紧固螺丝，螺帽和接头Checking of tightening set bolts, nuts and joints etc7). 电气系统ELECTRICALS 检查日期Date项目Item检查点Check point检查结果Inspection Result注释Remark电池Battery检查电压Checking of voltage 检查电解液的比重Checking of specific gravity of electrolyte检查电线和连接头Checking of electric wiring and connector
32、电珠Ceiling light确认亮度Confirmation of light up顶棚亮度Canopy light确认亮度Confirmation of light up探照灯Search light确认亮度Confirmation of light up8)放艇装置每月检查明细表Launch arrangement for lifeboat monthly inspection record检查日期Date编号No.检查对象Objects检查内容ItemsDAVITNo.1No.21.Davit放艇装置 活动部位加油 Apply lubricating oil to working pa
33、rts2.检查螺丝螺母 check bolts and nuts3.登艇梯 embarkation ladder检查登艇梯状态 condition of embarkation ladder4.限位开头 limit valve限位开头动作测试 actuation test for limit valve5.放艇部位 boat falls放艇部位状态 condition of boat falls6.活动部位加油 apply grease to boat falls7.放艇绞盘 boat winch活动部位加油 Apply lubricating oil to working parts8.检查
34、螺丝螺母 check bolts and nuts9.各部位动作试验 operation of each parts10.绞盘电机 motor for winch各部位状态 condition of each parts11.活动部位加油 Apply lubricating oil to working parts12.各部位动作试验 operation test13.救助艇检验 rescue boat inspection检验日期 (inspection date)：检验单位 (service station)：14.海上撤离系统检查marine evacuation system insp
35、ection检验日期 (inspection date)：检验单位 (service station)：15.*救生艇钢丝保养maintenance of falls上次换新时间Last renewal date, every 60 months 上次掉头时间Last Reversal date, every 30 months16.放艇说明launching instruction for life boat张贴状况fitting condition17.各种标志 kinds if marks张贴状况fitting condition18.救生艇及艇架在不承载任何人员时从积载位置荡出活络检查
36、（天气和海况许可时）（自由降落式救生艇除外）The davit can be launched without any loadable crew from its stowed position, which only depends on its gravity or stored energy generated from a source independent of the ships power supplies(if the ambient temperature permission) . This does not apply to the launching applian
37、ce for lowering free fall lifeboats .试验日期test date：救生筏每月检查明细表Life-raft Monthly inspection record检查日期inspection date编号No.检查对象Objects检查内容ItemsLife raftNo.1No.2筏箱Container阀箱的状况Loading Condition Of Container包裹的状态Condition Of Packing检查标志和名称Check Marking And Name Plate筏架Cradle筏架的状况Condition Of Cradle自动系索的
38、状况Condition Of Automatic Painter系固设备Lashing Apparatus钢丝,转轮,卸扣等的状态Condition Of Wire, Turn Buckle, Shackle Etc.释放单元的系固情况Lashing Condition Of Release Unit自动系固绳Automatic Painter自动系固的状况Condition Of Automatic Painter释放单元Release Unit释放单元的状况Condition Of Release Unit检查螺丝螺母和连接部分Check Bolts And Nuts Of Connect
39、ing Part人工释放绳Manual Release Painter手动释放绳的情况Condition Of Manual Release Painter救生筏的释放说明Launching Instruction For Life Raft张贴状况Fitting Condition气涨式救生筏的注意事项Caution Plate For Life Raft张贴状况Fitting Condition易断绳Weak Link易断绳的状况Fitting Condition Of Weak Link救生筏的年检Life Raft Inspection检验日期Inspection Date: 静水释放器的年检Hydrostatic Release Unit Inspection检验日期Inspection Date: 救生衣每月检查明细表Life jacket monthly inspection record编号No.放置地点Location数量Qty检查日期 Date外表Appearance 船名Mother ship name船籍港Port of registry束带Tightening Belts 救生衣灯Lights 哨笛Whistle反光带Reflective tape12
